ACS880-01-061A-2

ACS880-01-061A-2  变频

在变频器实际应用中，由于国内客户除少数有机房外，大多为了降低成本，将变频器直接安装于工业现场。工作现场一般有灰尘大、温度高、湿度大的问题，还有如铝行业中有金属粉尘、腐蚀性气体等等。因此根据现场情况做出相应的对策，如图2 所示。

1）变频器应该安装在控制柜内部。

2）变频器好安装在控制柜内的中部；变频器要垂直安装，正上方和正下方要避免安装可能阻挡排风、进风的大元件。

3）变频器上、下部边缘距离控制柜顶部、底部、或者隔板、或者安装的大元件等的小间距，应该大于300 mm。

4）如果特殊用户在使用中需要取掉键盘，则变频器面板的键盘孔，要用胶带严格密封或者采用假面板替换，防止粉尘大量进入变频器内部。

5）在多粉尘场所，特别是多金属粉尘、絮状物的场所使用变频器时，总体要求控制柜整体密封，专门设计进风口、出风口进行通风；控制柜顶部应该有防护网和防护顶盖出风口；控制柜底部应该有底板和进风口、进线孔，并且安装防尘网。

6）多数变频器厂家内部的印制板、金属结构件均未进行防潮湿霉变的特殊处理，如果变频器长期处于恶劣工作环境下，金属结构件容易产生锈蚀。导电铜排在高温运行情况下，会更加剧锈蚀的过程，对于微机控制板和驱动电源板上的细小铜质导线，锈蚀将造成损坏。因此，对于应用于潮湿和和含有腐蚀性气体的场合，对所使用变频器的内部设计有基本要求，例如印刷电路板采用三防漆喷涂处理，对于结构件采用镀镍铬等处理工艺。除此之外，还需要采取其它积极、有效、合理的防潮湿、防腐蚀气体的措施。

ABB 900060  DDR Switch cable 

ABB 3HAB2136-1  Teach pendant S3 

ABB 3HAB2151-1  Teach pendant S3 

ABB 3HAB2477-1  Floppy drive S2/S3 

ABB 3HAB2480-1  Floppy drive S4 

ABB 3HAB5386-1  Teach pendant S4 

ABB 3HAC14441-9  CMOS-battery 

ABB 3HNE00311-1  Teach pendant S4C 

ABB 3HNE00313-1  Teach pendant S4C 

ABB 4944016-2  Battery S3 

ABB 4944026-2  Battery memory board S2 

ABB YB161100-LH  Teach pendant S2 

ABB YB560100-EA  Teach pendant S3 

ABB YB560101-LA  Power supply 

ABB YT212002-BA  Rectifier 

ABB YT212002-C  Rectifier 

ABB YT212002-X  Rectifier 

ABB YB560103-CB DSQC236B DriveUnit 

ABB YB560103-CC DSQC236C DriveUnit 

ABB 3HAB2207-1 DSQC236D DriveUnit 

ABB YB560103-CD DSQC236G DriveUnit 

ABB 3HAB2207-1 DSQC236P DriveUnit 

ABB YB560103-CE DSQC236T DriveUnit 

ABB YB560 103-CL/5 DSQC241 PowerUnit 

ABB 3HAB 2210-1 DSQC300 Robot Computer 

ABB 3HAB 2216-1 DSQC314B PowerUnit 

ABB 3HAB 2219-1 DSQC316 Main Computer 

ABB 3HAB 2220-1 DSQC317 6MB Card 

ABB 3HAB 2236-1 DSQC321 4MB Card 

ABB 3HAB 5956-1 DSQC323 8MB Card 

ABB 3HAB 5957-1 DSQC324 16MB Card 

ABB 3HAB 2241-1 DSQC325 Main Computer 

ABB 3HAB 2242-1 DSQC326 Robot Computer 

ABB 3HAB7229-1 DSQC328 I/O Card 

ABB 3HAB 6182-1 DSQC335 Robot Computer 

ABB 3HAB8101-3/05D DSQC345B DriveUnit 

ABB 3HAB8101-3/08C DSQC345C DriveUnit 

ABB 3HAB8101-7/01C DSQC346C DriveUnit 

ABB 3HAB8101-8 DSQC346G DriveUnit 

ABB cable DSQC351 Interbus-S 

ABB 3HAC 0373-1 DSQC361 Main Computer 

ABB 3HAC3180-1 DSQC373 Robot Computer 

ABB 900054 1Gb SD-card S3/S4 DDR 

ABB 900056 1Gb SD-card S2 DDR 

  3HNE 00026 Teach Pendant 

  3HNE 00312-1 Teach Pendant 

  3HNE 00313 Teach Pendant 

  CHAA 3560-AXA Teach Pendant 

ABB 3HAB9271-1/01B DriveUnit Dummy DriveUnit Dummy 

ABB 57510001-AA DSCA 114 Print out board 

ABB 57520001-U DSCA 121 Communication board 

ABB 57160001-A DSDI 110 Digital input board 

ABB 57160001-K DSDO 110 Digital output board 

ABB YB161102-AH DSDX 110 Digital in/output board 

ABB 57160001-TP DSDX B001 digital in-output board 

ABB 57360001-U DSMB 124 Semiconductor memory board 

ABB 57360001-AN DSMB 125 Semiconductor memory board 

ABB 57360001-HG DSMB 127 Memory board 

ABB 57330001-N DSMC 110 Floppy disk controller 

ABB YB161102-AK DSPA 110 Axis computer 

ABB 57310256-AF DSPC 150 Central processor 

ABB 57310256-BA DSPC 153 Expand. single board computer 

ABB 57310001-GP DSPC 157 Expand. single board computer 

ABB YB161102-AD DSQC 103 Resolver power board 

ABB YB161102-AF DSQC 105 Display board 

ABB YB161102-BA DSQC 110 Programming board 

ABB YB161102-BS DSQC 115 Resolver power board + 2 analogue 

ABB YB161102-BE DSQC 116 Power supply 

ABB YB161102-BG DSQC 117 Resolver power board 

ABB YB161102-BU DSQC 124 Terminal unit 

ABB YB161102-BV DSQC 129 R/D board 

ABB YB161102-CH DSQC 136 Safety board 

ABB YB161102-CM DSQC 138 Terminal unit 

ABB YB560103-AC DSQC 202 Robot computer 

ABB YB560103-AS DSQC 208A External axis board 

ABB YB560103-AL DSQC 209 Analogue I/O board 

ABB YB560103-AM DSQC 210 Safety board 

ABB YB560103-AN DSQC 211 Power supply 

ABB YB560103-BF DSQC 215 Robot computer 

ABB YB560103-AZ DSQC 220 Programming board 

ABB YB560103-BD DSQC 223 PC Board digital I/O 

ABB YB560103-BE DSQC 224 PC Board combi I/O 

ABB YB560103-BK DSQC 227 Winchester interface 

ABB YB560103-BD DSQC 228 Safety board 

ABB YB560103-BN DSQC 230 Robot computer 

ABB YB560103-BS DSQC 233 External axis board 

ABB YB560103-BY DSQC 235A Rectifier 

ABB YB560103-BZ DSQC 235B Rectifier 

ABB YB560103-CA DSQC 236A Drive unit 

  DSQC 236B Drive 

ABB YB560103-CC DSQC 236C Drive unit 

ABB 3HAB2207-1 DSQC 236D Drive unit 

ABB YB560103-CD DSQC 236G Drive unit 

ABB 3HAB2245-1 DSQC 236H Drive unit 

ABB 3HAA3563-AJA DSQC 236P Drive unit 

ABB YB560103-CE DSQC 236T Drive unit 

  DSQC 239 Board - ABB RIO 

ABB  DSQC 241 Power supply 

ABB YB560103-CM DSQC 242 Programming board 

ABB 3HAA0001-CP DSQC 243 Serial measurement board 

ABB 3HAA3563-ACA DSQC 245 Serial measurement board 

ABB 3HAA3563-AAA DSQC 248 Programming board 

ABB 3HAA3563-AGA DSQC 249A Rectifier 

ABB 3HAA3563-AHA DSQC 249B Rectifier 

ABB 3HAA3563-AD DSQC 252 System board 

 E3HAC028756-001 DSQC 253 SMB unit DSQC 573 

 E3HAA3563-AMA DSQC 253 Serial Measurement Board 

 E3E 042816 DSQC 253 Exch. Serial mes. DSQC 253W 

 6369901-218 DSQC 253 Serial Measurement Board 

ABB 3HAB2211-1 DSQC 256A System board 

ABB 3HAA3563-AUA DSQC 258 Power supply 

ABB 3HAB8797-1 DSQC 266B Drive unit 

ABB 3HAB8798-1 DSQC 266C Drive unit 

ABB 3HAB8801-1 DSQC 266G Drive unit 

ABB 3HAB8800-1 DSQC 266H Drive unit 

ABB 3HAB8799-1 DSQC 266K Drive unit 

ABB 3HAB8802-1 DSQC 266T Drive unit 

ABB 3HAA3573-AAA DSQC 300 Board - Computer 

ABB 3HAB2210-1 DSQC 300 Board - Computer 

ABB 3HAB2233-1 DSQC 300 Board - Computer 

ABB 6369901-380 DSQC 300 Board - Computer 

ABB 3HAA3573-ABA DSQC 301 Programming board 

ABB 3HAB2209-1 DSQC 306 Computer board 

ABB 6369901-298 DSQC 306 Computer board 

ABB E3HAB2209-1 DSQC 306 Computer board 

ABB 3HAB3700-1 DSQC 313 Serial measurement board 

ABB 3HAB4259-1 DSQC 313 Serial measurement board 

ABB 3HAC9522-1 DSQC 313 Serial Measurement Board