HC-55长治市

HC-55长治市
将设计好的程序写入PLC后，先逐条仔细检查，并改正写入时出现的错误。用户程序一般先在实验室模拟调试，实际的输入信号可以用钮子开关和按钮来模拟，各输出量的通／断状态用PLC上有关的发光二极管来显示，一般不用接PLC实际的负载(如接触器、电磁阀等)。可以根据功能表图，在适当的时候用开关或按钮来模拟实际的反馈信号，如限位开关触点的接通和断开。对于顺序控制程序，调试程序的主要任务是检查程序的运行是否符合功能表图的规定，即在某一转换条件实现时，是否发生步的活动状态的正确变化，即该转换所有的前级步是否变为不活动步，所有的后续步是否变为活动步，以及各步被驱动的负载是否发生相应的变化。
在调试时应充分考虑各种可能的情况，对系统各种不同的工作方式、有选择序列的功能表图中的每一条支路、各种可能的进展路线，都应逐一检查，不能遗漏。发现问题后应及时修改梯形图和PLC中的程序，直到在各种可能的情况下输入量与输出量之间的关系完全符合要求。
如果程序中某些定时器或计数器的设定值过大，为了缩短调试时间，可以在调试时将它们减小，模拟调试结束后再写入它们的实际设定值。
在设计和模拟调试程序的同时，可以设计、制作控制台或控制柜，PLC之外的其硬件的安装、接线工作也可以同时进行。

PALL KLEENPAK FILTER HDC II filter 1.2 um 
PALL KLEENPAK FILTER HDC II filter 1.2 um 
MKS baratron 127AA-000010, 1 TORR 
MKS 253A-1-40-1 KF-40 Exhaust Throttle Control Valve 
RFPP 7520581010, RFPP AE RF50S 5KW RF power products  
AE APEX 1513, 1.5 K HALO A3L5L000BA140D1?11A, 0920-00067 
SensArray TC Thermal, Model 482-05-0002 
SensArray TC Thermal, Model 482-XX-0002 
MKS 653B-10-250-B THROTTLE VALVE 
AE Nigator RF MATCH 3155132-002 C, AMAT 0920-00004 
KF 16 Centering Seal, Orifice 033 Novellus 02-134129-33 
KF 16 Centering Seal, Orifice 032 Novellus 02-134129-32 
NEW CTI-CRYOGENICS ADSORBER COMPRESSOR 8500, 8510, 9600 
KF 16 Centering Seal, Orifice 029 Novellus 02-134129-29 
KF 16 Centering Seal, Orifice 025 Novellus 02-134129-25 
KF 16 Centering Seal, Orifice 019 Novellus 02-134129-19 
KF 16 Centering Seal, Orifice 018 Novellus 02-134129-18 
NEW Advanced Energy Nigator RF MATCH 3155132-001 D 
KF 16 Centering Seal, Orifice 014 Novellus 02-134129-14 
KF 16 Centering Seal, Orifice 024 Novellus 02-134129-24 
KF 16 Centering Seal, Orifice 000 Novellus 02-134129-00 
Richmond Static Control, Ionization Controller. 
NEW A&N CORP BLANK OFF 8 HOLE LF8100-400 SB, 6.5 INCHES 
NEW LESKER ASA1100X00 BLANK OFF, 8 HOLE , 11 INCH 
BLANK OFF P/N ASA750X00G, 4 HOLE , AMAT 0610-00050 
AMAT 0140-00317, Endura - Centura interface cable 
CTI 8115236G001 On Borard Retrofit Interface 
VAT PM-4 Adaptive Pressure controller  
Liquid mass flow controller LF-310A-EVD, 0.5g/min used 
AMAT 0020-25836 PVD Clamp Ring 8 inch, very clean 
Lam 230-140148-308 ESC, 8 inch, look new in Box 
KF 16 Centering Seal, Orifice 027 Novellus 02-134129-27 
Microscope Objective Lens SP 100X/1.25 OIL 0.17 
LEITZ WETZLAR NPL 20X/0.40 LEITZ ICR 20X/0.40 P 
OLYMPUS MDPLAN 80 0.90 F=180 Olympus IC 80 
AMAT 0010-0 09416 Etch Chamber RF Match, Untested used 
MFC Brooks 5866 N2 RT series, For Novellus gas box 
MKS Baratron 627A01TBC, 1 TORR with connection valves 
HORIBA CM-100 Digital Control Unit, Surplus 
Edward 1800 Pressure Controller, Very Good Cond. 
MKS Spectra HPQ2 and Spectra Vacuum Controller, RGA 
Qualidyne 5V 150A Switching Power Supply 10099, Surplus 
Edwards high vacuum 600AB, 10 TORR 
ENI OEM-25A-21091-5?1 RF Generator, 2500 W, 13.56 MHz,  
Sieger Gas detection DIGI-CAT and DIGI-CHEM with sensor 
RFPP RF Generator ICP-20P Model# 8511139050, 2000 W 
ENI DCG-200 DC Plasma Generator, AMAT 0190-08033 
Comdel, CPS-500AS RF Power source, AMAT 0190-13320 
Novellus Data Collection Breakout Box, 002-00283-000 
MKS baratron pressure switch 51A, 10 Pa 
KF 16 Centering Seal, Orifice 015 Novellus 02-134129-15 
KF 16 Centering Seal, Orifice 021 Novellus 02-134129-21 
KF 16 Centering Seal, Orifice 016 Novellus 02-134129-16 
KF 16 Centering Seal, Orifice 031 Novellus 02-134129-31 
KF 16 Centering Seal, Orifice 022 Novellus 02-134129-22 
KF 16 Centering Seal, Orifice 035 Novellus 02-134129-35 
KF 16 Centering Seal, Orifice 034 Novellus 02-134129-34 
KF 16 Centering Seal, Orifice 030 Novellus 02-134129-30 
KF 16 Centering Seal, Orifice 017 Novellus 02-134129-17 
KF 16 Centering Seal, Orifice 018 Novellus 02-134129-18 
KF 16 Centering Seal, Orifice 013 Novellus 02-134129-13 
KF 16 Centering Seal, Orifice 028 Novellus 02-134129-28 
Advanced Energy AE 3155039-000A TCM  
MATHESON GAS REGULATOR MODEL # 3818-580, USED 
Leybold Vacuum ION GAUGE lot's of 3, used 
AMAT 0150-16084 Chamber Interface Cable, Damaged 
HUNTINGTON VACUUM VALVE PV-150-SF, used 
Ultra Fab Technology UFT-46-3 Remote PCB, New 
Ultra Fab Technology UFT-48-8 Controler, Looks New 
Ultra Fab Technology UFT-620 Controller, Looks New 
MILLIPORE CDLD 1112E, 0-10 TORR, Used 
MILLIPORE CMHT-11S02 Pressure Manameter, Used 
MILLIPORE CMH4M1112E, 0-100M TORR, 0-10 VDC OUTPUT USED 
MILLIPORE CDLD1112E, 0-10 TORR, 0-10 VDC OUTPUT, used 
MKS Baratron Pressure Switch 51A, 1000 Torr, Lot of 2 
Rorze RC-204A axis control Generate Master, looks New 
SYSMELEC HANDHELD ROBOT & AUTOMATION CONTROLLER 81 
TYLAN GENERAL, MDVX-100B, motor driven throttle valve 
EDWARDS D14641000 AIM-S-NW25, ACTIVE GAUGE 
STS Multiplex ICP chamber, Plasma Source, good parts 
Novellus Sequel HDP Speed chamber body 
WILLIAMS advanced materials thin film products 
UNIT UFC-1660 CL2 200 SCCM and O2 1 SLPM, lots of 2  
HPS MKS insulator, heat blanket, KF40 flange  
CTI-CRYOGENICS 8300 compressor, 8001 controller 
CTI-CRYOGENICS 8300 compressor, 8004 controller 
alcatel pump 2033, leybold D90A, leybold D30A, Vac pump 
Olympus MDPlan 80 Microscope IC80 Lens 0.90/F=180 
Leitz Wetzlar Microscope objective lens NPL 20X/0.35 
Microscope Objective Lens SP 10X/0.25 
Microscope Objective Lens SP 4X/0.1 0.17 
Microscope Objective Lens SP 40X/0.65 0.17 
STEC LF-310A, TEPO,0.25 g/min, liquid flow controller 
Tylan 2900 MFC FC-2900M, CF4, He, CF4, CL2, lot's of 4 
Tylan 2900 MFC FC-2900M-EP, N2, 20 SLPM, lot's of 2 
Tylan 2900 MFC FC-2900M-EP, O2, 20 SLPM, lot's of 2 
Tylan 2950 MFC FC-2952M 4V metal, Co, CHF4, lot's of 2 
GRANVILLE PHILLIPS, ION VACUUM GAUGE, type EXT-Y 
MKS Spectra HPQ2, Microvion plus, Resist torr, lot's 3 


MicroMaster WP6311-AAAA western pacific times corp 


Vacuum Gauge controller MIG-052 ANELVA CORPORATION 


ELECTRODE VOLTAGE METER CONTROLLER A13-57936-02 


YAMABISHI ELECTRONIC POWER CONTROLLER YAPC-100-3.5 


ANELVA CORPORATION ATC-46 SCHEMATIC H11-05299 


RF MATCHING UNIT VSP-0971 


BELLOWS CYLINDER 80*60STMV lot's of 2 


MKS Throttle Valve 153-E, used 


Tellabs 812572, 2572 64 ms T1 echo canceller, card 


Digital Link DL030 MNGMNT, PCBA 300-01908-01  


AMAT 0100-20009 System Stepper Distribution PCB,  


AMAT 0150-12066 Signals Cable, Looks 


18 New AMAT# 3300-06439 FGT TBG PLUG 1/4T ONE-TOUCH 


Auto-Vacuum Valve L C001, Vacuum gauge, used 


MKS Baratron Pressure Switch 41A, 100 Torr 


MKS Spectra vacuum controller LM59, lot's of 3 


STEC MFC SEC-4400MC, N2 and O2 TOTAL of 5 units 


OSRAM BPX61 PHOTODIODE 


ENI RF Generator OEM-12A, 1250W at 13.56 MHz 


Bettcher Process Services Switch Panel, MODEL 985V4  


Rinse Controller, Bettcher Process Services, MODEL 985D 


ENI RF Generator LPG-6A , Low Frequency, used, as is 


Light Source I 150, Looks 


NEW FOCUS, AFOP MODEL GYCW-4 FIBER OPTIC Work Station 


PRI PCB BM17756L01/E, 9950PRI 


ATI Technologies 109-43200-10 


American Megatrends Hyper Disk 795005990, E7952000.04 


COMPAQ BOARD, ASSY 006047-001, P03560B25EIVNI 


Irvine Optical Corp. U22BPL1 PCB 


ProgramMation C198/-90, BM23995R, HPRI0031T-M, PRI 


US Robotics 000840-06 33.6 ISA Internal Data/Fax Modem 


STI 16831 PCB, 1683-01-0047, 2601800  


109-19301-10 ISA Mach 64 Graphics Card 


Kalex 656993-002, PB656982-002, Ethernet ISA RJ45 


Swagelok 6LVV-DPVVR4-P-C?, NEW in the box, lots of 8 


SWAGELOK 6LVV-DPFR4-P1-0?, lot's os 2 


EG&G Current Sensitive amplifire Model 181  


Newport Laser diode driver model 6530 


US Robotics 005687-53 ISA Internal Modem Card 


Pc PCNAU504 Adapter Isa 


HAMAMATSU 56489 C6219 


Thermolyne Type 10100 stirring hot plate SP10105B 


MNEMONICS E1-100-10, SEMITOOL 4012-10 REV 1-0 


AMAT VACUUM FORELINE AND FLANGE 0040-30354, lots of 4 


MICROSCOPE OBJECTIVE 10/0.25 160/- 


MICROSCOPE OBJECTIVE PLAN 10/0.25 160/0.17 


MICROSCOPE OBJECTIVE 4/0.10 160/- 


STEC LF-310A, TEPO 0.25 g/min Liquid Flow Controller 


STEC LF-410A-EVD, TEPO 7.0 g/min Liquid Flow Controller 


STEC Liquid flow controller, LF-410A, TEOS, 4.0g/min 


STEC LF-410A-EVD, TEOS,10 g/min, liquid flow controller 


STEC LF-410A-EVD, TEB 2.0 g/min, TiCl4 2.0g/min , LFC 


BODINE ELECTRIC 42A3FEPM-E4 GEARMOTOR, 130 VOLTS, CLEAN 


Plate, Baffle, Upper 715-011912-083 


Hitachi High, Asher Reflector- Legacy 233106723 


AMAT 0240-34336 Throttle Valve, AMAT 3700-02406 Oring 


Malena, Flow, Switch 233128072 


AMAT 3880-01085 Washer BLVL .3750D x .1901D 


BOC Edwards Water Jet Kitall Mods 85 316SS 


Assy, N/F, Controller Cable 23324465 


Rear Upper Cross Piece 7580 


Angled, Anode, Ring, Sleeve 500062645 


AMAT 0015-00423-P1 Bulb, 150W Auxillary  


Aligner up/down transmission #7458, 233435333 


AMAT 0100-00975 STEPPER CONTROLLER PCB  


AMAT 0100-76124 DIGITAL I/O BOARD, REV B 


SVG STATION CPU BOARD 80166F2-01 


Horiba Stec LF-310A-EVD TEPO 0.1g/min Liquid mass meter