1756-SPESMNRMXT

1756-SPESMNRMXT
1756-SPESMNRMXT
1756-SPESMNRMXT


　每家生产工厂都很关注电力管理。
　　自主提供部分电能的工厂尤其关注这一点，特别是在工厂需要依靠电力实现持续运行时。位于密歇根的一家造纸厂便是如此。
　　断电可能导致停机、生产损失以及设备损坏，代价高昂。为缓解此问题，电力质量的重要性日渐凸显;由于容差范围窄，设备和制造过程中很难利用质量差的供电。
　　造纸厂尤其受到此类问题的困扰。
　　在与罗克韦尔自动化电力及能源管理解决方案小组(PEMS) 合作之前，该造纸厂一直在承受每年四至七次断电带来的负面影响。
　　为帮助像们这样每天依靠电力实现赢利的工厂，PEMS专门设计了一套解决方案来连续测电力，并控制负载的自动切换，以维持工厂的正常生产。除此之外，整套解决方案还能提供分析和培训，帮助工厂员工更深入地了解电力管理挑战，以及如何应对这些挑战。
　　面临的挑战
　　面临的挑战是如何掌握电力使用情况，并在不中断造纸过程的前提下切换电源。
　　该厂有两台造纸机专门生产用作包装材料的瓦楞纸板。工厂总负载的60%由现场的15兆瓦涡轮发电机承担，其余部分则由当地公共电力提供。过去，在当地公共电力停止供电时，涡轮发电机就需要满足整个工厂的负载需求，进行导致其跳闸离线，断电屡有发生。
　　这些电力故障造成整个工厂长时间停机、设备受损、生产受阻。之后，还需要耗费大量精力使工厂恢复生产。
　　解决方案
　　在权衡PEMS解决方案的价值以及断电造成的收益损失之后，该公司认为这一投资物有所值，因此决定由PEMS开发一套紧急负载卸载系统解决方案。
　　PEMS为该厂提供了一套负载管理及控制系统(LMCS)，其中配备的自动切换系统可以快速从正常运转模式转换到应急模式，以满足工厂中关键的电力需求。PEMS解决方案基于成熟且极为可靠的Allen-Bradley可编程逻辑控制器和电力测器系列产品，可使涡轮发电机、锅炉及关键设备持续运转，保证工厂造纸过程不被中断。该系统能将非关键负载切换为离线状态，并能在不到266ms或12个周期的时间内将工厂从公共电网中隔离出来。
　　LMCS可对电压、电流及其它电力参数进行实时视。其中包含的紧急负载卸载算法可实现对非关键负载控制(卸载)的快速响应。切换过程只需几毫秒，因此，当主要的公共电力中断时，完全可以通过辅助电源维持关键负载的运转，从而维持生产。LMCS还会提示和记录异常事件(报)，连续视公共电网提供的电力，在遇到紧急情况时几乎可以瞬间自动将负载切换为离线状态，从而确保13.8kV线的稳定。
　　在构建系统之前，PEMS先进行了现场调查和需求分析。们制定了包含I/O及电力测器详细列表的功能规范，确定了将要采用的通信网络，并且明确了将所有功能整合在一起所需的硬件和软件。
　　此外，们还与工厂沟通确定了人机界面(HMI)站的配置，同时定义了将未来扩展考虑在内的自动化控制算法和要求规范。
　　PEMS提供的解决方案中还整合了其它一些服务，例如软件和硬件工程、设计和起草、面板装配以及PLC编程。工厂验收试验也顺利执行。整个解决方案安装到位后，工厂得到了一套终文档，从而完成了所有设计及操作知识的交接。


1494C-DR222-A6-D1-E 200A Cable Operated Disconnect Kit
1493-N1 KIT,OVERLOAD RELAY RESET FOR STARTER
103S-DWDJ2-CC25B-KY 18 - 25 A MCS Starter & Circuit Breaker
103T-DTA3-RC10XC-E1D-KN IEC Combination Starter
150-C135FBD-3-6P NEMA 135A 150 Motor Controller
194R-B32-FCS 32 A BS88 with Indicator Fuse Carrier
100-K09ZS300M IEC 9 A Contactor
ALLEN-BRADLEY 2711-K5A20 PANELVIEW 550 2711K5A20 CLEAN TESTED GOOD COND.
20DD125A3ENNAEGNE PowerFlex 700S 125 A 100 Hp AC Drive
193-EDN E1 Plus Jam Protection Module
107S-ATZJ3-CB16C-TE 1 - 1.6 A Reversing Starter & Breaker
20BC085A3AYNAEA0 PowerFlex 700 85 A 45 kW AC Drive
455880-B21 456095-001 HP VIRTUAL CONNECT 10GB ETHERNET
20DD022A3EYNANBSE PowerFlex 700S 22 A 15 Hp AC Drive
190S-AND2-CB16C-A20 1 - 1.6 A 190S Compact Comb Starter w/CB
20BD096A3ANNAEC0 PowerFlex 700 96 A 75 Hp AC Drive
190E-ANKD2-CB10C 0.63 - 1 A 190E Eco Starter with CB
190E-AND1-CB16C-KY 1 - 1.6 A 190E Eco Starter with CB
1756-L73SXT Logix 5573SXT Automation Controller 8/4M
20AD034A0AYNADG0 PowerFlex 70 34 A 25 Hp AC Drive
150-F480FBD-1F 150 Motor Controller
ALLEN-BRADLEY 1794-1B16 INPUT FLEX I O MODULE SERIES A 10-31.2 VDC NNB
104S-C16ZJ210BC 16A MCS Safety Reversing Contactor
1492-MS6X12V51-100 Wiring System 6mm x 12mm 80 Mkrs/Crd
194L-HA-451 ACTUATOR HANDLE FOR LOAD SWITCH
20AD011A0AYNANG1 PowerFlex 70 11 A 7.5 Hp AC Drive
1492-MS5X12V1-20S Wiring System 5mm x 12mm 80 Mkrs/Crd
Allen Bradley 1746-OW16 SLC500 Relay Output Module SerC
ALLEN-BRADLEY 1788-CNC/1788C​NC FlexLogix ControlNet Communication Module NS
20DC920ACENNBCASE 920 A 500 kW AC Drive
20AB042C3AYNAEC0 PowerFlex 70 42 A 15 Hp AC Drive
2090-CPWM4DF-16AF02 MP-Series 2 m Length Power Cable
20BB9P6A3AYNBCC1 PowerFlex 700 9.6 A 3 Hp AC Drive
190S-ANDJ2-CA40C-KY 190S Compact Comb Starter w/CB
100-C90DJ200 90 A 100-C contactor
1492-CONACAB005E 0.5m Cab Compat w/LA003
190S-AND2-DB25C-KN 190S Compact Comb Starter w/CB
1492-EWPJ8 Electrical Warning Plate 8 mm
1492-M5X5H71-80 Wiring System 5mm x 5mm 200 Mkrs/Crd
194E-FA40EX-P11-PE-6 Load Switch
1790-0V16X LDX I/O, 24 VDC, 16 SINK OUT EXPANSION, D-SHELL
ALLEN-BRADLEY 1769-OB32 COMPACT I/O 32 PT. SOURCING OUTPUT MODULE IN BOX
3INA BEARING Bearings PN NK19/20
2100PE-WLHXW11/1 LVMCC
100S-C30D32C 30 A MCS Safety Contactor
1757-PFBEXP005 PROFIBUS INTERFACE MODULE EXPANSION FROM 3 TO 5 MAX
20AD2P1A0AYNNEC0 PowerFlex 70 2.1 A 1 Hp AC Drive
1441-PEN25-CASE-S Enpac Service Case
22B-A2P3C104 PowerFlex 40 0.4 kW (0.5 Hp) AC Drive
1492-M5X5H161-170 Wiring System 5mm x 5mm 200 Mkrs/Crd
104-C09J22 9 A Reversing Contactor
107T-AWD7-RB40C-E1C Rev. Combination Starter
2090-KPBM4-06AA MP-Series Power and Brake Connector Kit
Acme Electric Control Transformer TA-1-81144 150 VA
Allen Bradley Panelview Plus 2711P-RN15S /B 2711PRN15S
2711P-RDB12C PV PLUS 1250, KEY/TOUCH SCREEN DISPLAY MODULE
1233X-BNH-A2F-38 NEMA Pump Panel,Extra space,Cype
Allen Bradley SLC 500 Card Input Module 1746-ITV-16
190E-DNEJ2-CC16C 10-16 A 190E Eco Starter with CB
20BR125A0AYNANC0 PowerFlex 700 125 A 100 Hp.. AC Drive
23B-D017D10DNN-P6 23B AC Packaged Drive
1497-A-BASX-1-N Control Circuit Transformer
153B-B97FBDB-48-3-4G-4R-89F22-HJ2-NB-NI-UL Controller w/Circ. Breaker&IC
190E-AND1-CA25C-R 0.16 - 0.25 A 190E Eco Starter with CB
100-C37L00 37 A 100-C contactor
1492-MS8X12VU1-20 1492-MS8x12 marker card Wiring System
1410-FOA50 Motor Winding Heater
105-C09ABD1C-3 Reversing Starter
Allen Bradley 2094-XL75S-C2 /A Line Interface Module 230-460V 75A
153H-DF251FBD-57-6PK SOLID-STATE CONTROLLER WI
1485C-P24W5-Z5 DeviceNet Physical Media
1485R-P5F5-C DeviceNet Physical Media
112-C12ACE1C-6P IEC Enclosed Combination Starter
103S-ATD2-DB40S 2.5 - 4 A MCS Starter & Circuit Breaker
20AC2P1A3AYNANG0 PowerFlex 70 2.1 A 0.75 kW AC Drive
20SD600NEN PowerFlex 600 A SCR Bus Supply
1746-OB16 SLC 16 Point Digital Output Module
Allen Bradley DC Servo Controller 1388B-40138​8B401388B-A​V4O1388B4O
103H-BFCZJ2-DC16X-S01 IEC Enclosed Combination Motor Controlle
ALLEN BRADLEY 1771-OZL 0-24V CONTACT OUTPUT MODULE LNC
20BC1P3A3AYYAEC0 PowerFlex 700 1.3 A 0.37 kW AC Drive
2090-XXNFY-S25 CABLE,NON-FLEX,MOTOR FEEDBACK,Y,25M
20BD2P1A3AYNACN0 PowerFlex 700 2.1 A 1 Hp AC Drive
14C221 MIN/FLEXPAK PLUS TACHOMETER FEEDBACK KIT
153H-F251FHD-49-3-4G-4R-6PX Controller w/Circuit Breaker
20AB028C3AYNANC0 PowerFlex 70 28 A 10 Hp AC Drive
20AD1P1C3AYNNDC1 PowerFlex 70 1.1 A 0.5 Hp AC Drive
1494C-DJ233-A4-B-F 30A Cable Operated Disconnect Kit
103T-ATD3-RC10C-C2B-KN-TE Combination Starter
20BE2P7A3AYNAED0 PowerFlex 700 2.7 A 2 Hp AC Drive
109-CAKD0-E1C-2-4G IEC Enclosed Non-Reversing Starter
1791DS-IB8XOB8 Guard I/O 16 Point Digital Comb Module
1492-MR6X12H101-150 1492-MR6x12 marker card Wiring System
1497D-A18-M10-0-N GEN PURPOSE TRANSFORMER
Reliance Communication Module 5704
194L-HA-350 Load Switch Operating Handle
190S-ENDJ3-FC32C-R11 23 - 32 A 190S Compact Comb Starter w/CB
20BB015A3AYNBNB0 PowerFlex 700 15.3 A 7.5 Hp AC Drive
Allen Bradley Micrologix Compact I/O Power Supply 120/240 VAC input 1769-PA4
20BD4A3NYYAND1 PowerFlex 700 3.4 A 2 Hp AC Drive
194L-HCB-001 Load Switch Operating Handle
Allen Bradley 1771IAD Ser D Input Module
ALLEN BRADLEY 1794-IT8 1794IT8 SER A
100S-C09D05C 9A MCS Safety Contactor
104-C12B22 12 A Reversing Contactor
194R-N30-1753-PBN1 Non-Fused Fused Disconnect Switch
20DH1K0N0NNNBNANE PowerFlex 700S 1030 A 560 kW AC Drive
152H-F201FBD-52-HC3 Controller w/Fusible Disconn
20BC325N0NNNNNC0 PowerFlex 700 325 A 180 kW AC Drive
1803-EEM20E12 EEM,32 PULSES, 24V DC, NEMA 12 ENCLOSURE
20AD5P0M3AYNANC0 PowerFlex 70 5 A at 3 Hp 20A AC drive
194R-KN30-1753-PB-A12 Non-Fused Fused Disconnect Switch
140U-G1C2-C25 25 A Molded Case Circuit-Breaker
21T-179615-943-9LC Carrier LiquiFlo 2.0 AC Drive
20DC261A0ENNBNASE 261 A 132 kW AC Drive
112-3ABDE1F-3-7-98 Fusible Disconnect Combination Starter
Allen Bradley 150-B54NBD
D6200-6.4.12RU PLC5 PROG. SW I/O CONFIGURATION (RUSSIAN)
1394C-CONN-KEY KIT 1394 5&10KW POWER&SHUNT CONN W/KEY
1734-OV8E POINT I/O 8 Point Output Module
ALLEN BRADLEY 1771-ASB/E NSFP 1771ASBE
20BE9A3AYNAND1 PowerFlex 700 3.9 A 3 Hp AC Drive
1492-ACABLE150Z Analog Cable Wiring System
100S-C23DJ14BC 23 A MCS Safety Contactor
190S-AND2-JB25C-KY-V 190S Compact Comb Starter w/CB
ALLEN-BRADLEY MICROLOGIX 1761-L16BWA Series C FRN3.0
100S-D115EN22BC 115 A MCS Safety Contactor
1585J-M4HBJM-1 RJ45 Ethernet Media
Allen-Bradley 1305-AA02A
1771-OBDK CONFORMALLY COATED, 10-60V DC OUTPUT MODULE 16 OUTPUTS
20AE052A0AYNANC0 PowerFlex 70 52 A 50 Hp AC Drive
ABB ASEA BROWN Boveri DSQC 108 YB161102-AN/1 CIRCUIT BOARD Backplane Connector
140M-I8E-D10-TX MOTOR PROTECTION CIRCUIT BREAKER
1000A-0242-44626 EPI AC REM CH A/B
103H-AFBB2-CC10X-1 Combination Motor Controller
194L-Y12M-1754-6N Control and Load Switch
112-C09FCXXX-1-6P IEC Enclosed Combination Starter
107S-ATD3-DB25C-SP-TE 1.6-2.5 A Reversing Starter & Breaker
150-F85FBD-6P 150 Motor Controller
22-RFD180 PowerFlex EMC Filter Kit
ABB AS Robotics Teach Pendant TPU2 3HNE-00311-1 Rev 13 349-3532-09
20BD077A0AYNANN0 PowerFlex 700 77 A 60 Hp AC Drive
1494C-DN60-A3-B1-FF Cable Operated Disconnect Kit Cable Disc
1794-IB16K CONFORMAL COATED, 24V DC SINK INPUT MODULE, 16 PT
20BC125A3AYNANA0 PowerFlex 700 125 A 55 kW AC Drive
100-C23ZD200 23 A 100-C contactor
140U-KRP3-D20 200 A Rating Plug
100-K05V00M IEC 5 A Contactor
AB PLC Output Module 1746-OB16 1746OB16 NIB
20DJ650N0NNNBCANE PowerFlex 700S 650 A 500 Hp AC Drive
107T-DTZJ3-RC25C-C2C Rev. Combination Starter
20BD180A0ANNANC0 PowerFlex 700 180 A 150 Hp AC Drive
1492-CABLE100RTBB Digital Cable Wiring System
103S-ATD3-CB40C-KY-TE 2.5 - 4 A MCS Starter & Circuit Breaker
140DAO84220 TESTED Modicon AC Out 140-DAO-842-20
20BD180A3AYNANC1NNAX PowerFlex 700 180 A 150 Hp AC Drive
2090-CFBM7DD-CEAF02 2 m Length SpeedTec Flexible Cable
Allen Bradley 1771-IBD Input Module 29778
20BD052M3AYNANC0 PowerFlex 700 52 A 40 Hp AC Drive
1769-IT6 6 CHANNEL THERMOCOUPLE/MILLIVOLT INPUT MODULE
1585J-E8HBJM-35 Ethernet RJ45 Patchcord,STR+90DEG 35M L
1492-MS8X9H61-70 Wiring System 8mm x 9mm 56 Mkrs/Crd
2711-K9C9 ALLEN BRADLEY
20BD022A3NYYADC1 PowerFlex 700 22 A 15 Hp AC Drive
20BD011A0AYNAEB0 PowerFlex 700 11 A 7.5 Hp AC Drive
4 PCS Omron Switch Limit Roller Plunger Z-15GQ22-B
194R-NN200P31R3 KIT,DISCONNECT SW 600V AC MAX
104S-C23EJ210BC 23A MCS Safety Reversing Contactor
20F14NC104JA0NNNNN PowerFlex 753 AC Drive
150-C85FBD-1-3-4R-6P-90 NEMA 85 A 150 motor controller
103T-ATDJ2-RC10B-E1E IEC Combination Starter
20DJ500N0ENNBDANL PowerFlex 700S 500 A 450 Hp AC Drive
Allen Bradley 1745-LP151 /C SLC 150 Controller FRN 6
190E-AND2-CB40C-KY 2.5 - 4 A 190E Eco Starter with CB
1485C-P18M5-C DeviceNet Physical Media
1000DE-XX-XX-W I-R CD8 INTELL PANEL
21G1ALD430AN0NNNNN-HD-P3 PowerFlex Air Cooled 755 Packaged Drive
20BD027A3AYNAEC0 PowerFlex 700 27 A 20 Hp AC Drive
20LF380N0QNNENA0KA PowerFlex 700L 380 A 355 kW AC Drive
103T-AWD2-RB63C-D1C Combination Starter
20BP105A0ANNANC1 PowerFlex 700 105 A 55 kW.. AC Drive
Allen Bradley 2711-K6C1L1 2711K6C1L1 Panelview XLNT
20DD011A3EYYAEBNE PowerFlex 700S 11 A 7.5 Hp AC Drive
1791-IOBW BLOCK I/O, 24V DC, 64 PT MODULE
20-PP13027 DISCHARGING RESISTOR 2X8K FR10+ SERIES B
112-C09FBJE1C-3-6P Fusible Disconnect Combination Starter
20AE041C3AYNANC0 PowerFlex 70 41 A 40 Hp AC Drive
1492-CABLE010P Digital Cable Wiring System
1606-XLS480EE 24-28V DC 480 WATT POWER SUPPLY
2090-CFBM6DD-CCAA03 TL-Series 3 m Length Feedback Cable
1485AS-C3 DEVICE NET
1336-BD-SP6A DIODE
150-F251FBD 150 Motor Controller
20BD535N3ANNNNC1 PowerFlex 700 535 A 450 Hp AC Drive
Allen Bradley 1771-OB 1771OB PLC 5 DC Output Module
1746-R15 SLC Replacement Retainer Clip
20DK325N0NNNBCASE PowerFlex 700S 325 A 350 Hp AC Drive
1494C-DNX30A3HH cable operated disconnect kit Cable Disc