1771-A1BK

1771-A1BK
1771-A1BK
1771-A1BK


宝钢二期烧结工程主排风机设备1991年投入运行。主排风系统由2台21000m3 /min风量，1 7 . 6 4 k Pa (1800mmWG)静压差的双入离心式风机机组组成，主拖动电机为 2×7800kW，10kV无刷励磁同步电动机，2台电机共用一套3.4MVA变频软起动装置起动。该装置1991年投产以来，故障较多，启动成功率低。其主要原因是装置设计容量偏小，系统老化，参数漂移。随着宝钢生产节奏的进一步加快，对烧结矿生产的要求越来越高，为确保烧结生产的稳定运行，基于2DL主排风机起动装置及励磁装置的实际现状，对其进行整体改造的确势在必行。
　　二、改造范围简述
　　本改造项目不涉及主排风机本体及油泵、风门等辅机设备。对目前使用状况尚好的为辅机及辅助设备供电、控制服务的MCC柜以及关联二烧结主控制系统的远程I/O柜予以保留利用。
　　对于10kV的高压开关，保留，能源部设置的辅助继电器、原有中继端子柜也予以保留。
　　高压变频装置、励磁柜、操作控柜拟引进设备，对其进行整体更换。与变频装置配套的输入、输出变压器则由外商提供详细技术参数及制造要求，由宝钢方面择优从内制造厂订货，变压器采用油浸式变压器。
　　考虑到本改造项目新上一套主排风机起动装置及励磁系统，而且在新系统安装调试好以前，老系统还要能运行使用，要求新系统电机空载或带风机负荷调试只能利用2DL年修的七天左右时间完成。当新系统调试过程中出现问题，不能如期接班时，还需老系统作为后备，维持2DL的正常生产。
　　新起动系统10kV运行总线的两路旁路开关到二台同步电动机的馈电，接至老系统运行总线下的两路旁路开关，主排风机室电动机那段电缆仍用旧有电缆。新老系统试车或运行需重接高压柜的高压电缆进行相互切换。
　　原有老系统的励磁柜、操作控盘拆除后，不再恢复。而新装的本次引进系统之励磁柜及操作、控制、视盘将要兼顾新老系统，这部分设备做成与新老系统兼容且具双向切换功能。
装置特点
　　本高压变频器作为软起动器可以连续起动，起动时间小于200秒，起动电流不超过电机的额定电流。该产品特点为：
　　可靠性高。该产品采用6500V,1500A 的高压SGCT器件，器件数量少，耐压及电流裕量大，变频电流小，器件开关损耗少，设备可靠。
　　输入波形好。变频整流器采用多脉冲形式(18脉冲)，总体谐波畸变THD小于 5%，直接满足IEEE519-1992及标的谐波标准。
　　输出波形好。无需增加任何选项， PWM电流型变频器直接输出完正弦波形，不存在转矩脉动，无潜在共振问题。逆变时无dv/dt及di/dt的产生，谐波畸变THD小于5%，连接变频器及电机之间的距离可长达15km。
　　起动性能好。PowerFlex7000采用直接矢量控制技术，本方案选用无编码器的矢量控制，转子的位置可直接检测，起动力矩为95%额定起动转矩。
　　使用简单。人机接口为大屏幕液晶显示操作员终端。变频器的状态，输入输出变量，自诊断结果，故障报等信息均可显示在屏幕上。
　　维护方便。高集成度的SGCT器件及 PowerCage机架的使用提高了系统模块化程度，从而保证了功率模块的更换时间小于5分钟。


1746-RL55 REPLACEMENT OCTAL LABEL KIT FOR CTLG # 1746-OBP16 (KIT INCLUDES 1 OCTAL LED LABEL & 1 DOOR LABEL)
20BC043A3AYNAND0 PowerFlex 700 43 A 22 kW AC Drive
9393-RSCOMP500R SUPT REINSTATEMENT CONTRACT FOR 9393COMP500 COMPANION FOR SLC 500 AND MICROLOGIX SOFTWARE
Allen Bradley 1771ID Isolated 120V AC/DC input module
140U-I3C3-C60 60 A Molded Case Circuit-Breaker
1370-DBL63 DYNAMIC BRAKE RESISTOR,2HP,240VDC
1232-CNA-A2J-25R NEMA Pump Panel,Slim lineDisconnect
140M-C2T-C16-TE MOTOR PROTECTION CIRCUIT BREAKER
1492-SP1C070-N SUPP. PROTECTOR MINI CIRCUIT BREAKER
1494C-DR233-A4 30A Cable Operated Disconnect Kit
1485G-P6D5-Z5 DeviceNet Physical Media
109-3FAE1T-1-7 Non-Reversing Starter
20BB052A3AYNACD1 PowerFlex 700 52 A 20 Hp AC Drive
21T-380097-A05 Kit LiquiFlo Choke
193-E3DEMO1 E3 Plus Demo Case
190S-AND2-DB25C-KN 190S Compact Comb Starter w/CB
20BB130A0AYNANN0 PowerFlex 700 130 A 50 Hp AC Drive
ALLEN BRADLEY 1741-A120A INPUT MODULE
Allen Bradley 1756-IB15D Input Module 10-30VDC
Allen Bradley SLC 500 1746-OX8 -0X8 Output Module Sealed Box NIFSB
20BC085A0AYNADB0 PowerFlex 700 85 A 45 kW AC Drive
1492-PBC6 Power Block Cover
1492-M6X10V1-50 Wiring System 6mm x 10mm 120 Mkrs/ Crd
140M-I8E-C80-CX MOTOR PROTECTION CIRCUIT BREAKER
150-C201NBD 150 Motor Controller
1494V-DH666-E-F-G 60A Variable-Depth Disconnect Kit
ALLEN BRADLEY 1771-IAD/D 120V AC/DC INPUT MODULE
1492-M7X12HL1 Wiring System 7mm x 12mm 108 Mkrs/Crd
1000GD-400EAM466 GDI, EAM FAMILY, 230V, 100HP FV
20DB9P6A3EYNAEBSE PowerFlex 700S 9.6 A 3 Hp AC Drive
ALLEN BRADLEY 1771-OA AC OUTPUT MODULE 120V SERIES B
1494V-DJ606-A-D-E-HH Variable-Depth Disconnect Kit Disconnect
1585J-M4TB-10 RJ45 TO RJ45 PLENUM
Allen-Bradley 700-CF400Z
1756-STRT3IT CONTROLLOGIX STARTER KIT ITALIAN
1232X-BNB-A2C-24R NEMA Pump Panel,Extra space,DS Type
20DD8P0A3EYNA6CNL PowerFlex 700S 8 A 5 Hp AC Drive
20BC015A0AYNANC1 PowerFlex 700 15.4 A 7.5 kW AC Drive
1792D-CB18P MAXUM ROUND MEDIA 18MM BASE, PASSTHRU FOR DNET SINGLE 18MM AUX POWER CONNECTOR
30 Amp Marathon 3 Pole Fuse Terminal Block 6R30A3B
20BC205A3AYNANC0 PowerFlex 700 205 A 110 kW AC Drive
Allen Bradley 2711P-B7D2 Panelview Plus 700 Touch WOW
100-C09ZG400 9 A 100-C contactor
152H-F361FBD-57-3-6P-8L-HC3 Controller w/Fusible Disconn
1757-PFBUPG003 PROFIBUS LIC UPG 3 IOMS ONE RELEASE LEVEL
1497-A-AXJK-1-N Control Circuit Transformer
100-C85N10 85 A 100-C contactor
1492-M6X5H251-300 Wiring System 6mm x 5mm 200 Mkrs/Crd
153H-C317FBD-56-1-3 Controller w/Circuit Breaker Enclosed Mo
1232X-BNB-4R-6P-24R NEMA Pump Panel,Extra space,DS Type
21BD156A3ANNAND0NNNN-ND-B0-C5-L1-P3 PowerFlex 700 Packaged Drive Bulletin 21
103H-AFHH2-DB40X IEC Enclosed Combination Motor Controlle
1769-OF8V ALLEN BRADLEY Micrologix Voltage Output Module 2 1769-0F8V
1756-L7SP Logix L7SP SIL 3 PLe Safety Partner
AMD Phenom 1045T 2.7G CPUBIOSTAR CrossFireX SATA6 USB3 GIGABIT AM3 Motherboard
112-C09FBDD1D-3-4R Fusible Disconnect Combination Starter
200V4160 GV3000 V Per Freq - Vector AC Drive
109-CCEKD0-E1R-2 IEC enclosed Non-Reversing Starter
103T-ASD3-RB63C-C1A-TE IEC Combination Starter
6643-P3A0R 6643-P3A0 SOFTWARE SUPPORT REINSTATEMENT
140U-H6C3-C20-HB H frame molded case circuit-breaker
AllenBradley1771-OD16/BIsolatedOutputModuleD01
1770-CD7 Data Highway 700-700 ft Length Cable
9358-BBKEY30ENE RSBIZWARE BATCH BACK-UP KEY 30 UNITS
20DD077A3EYNAEANE PowerFlex 700S 77 A 60 Hp AC Drive
190S-ANF2-CB25C-KN 190S Compact Comb Starter w/CB
153H-F85FBDB-47-3-6P-8L-20E Controller w/Circuit Breaker
1756-N2 ControlLogix Empty Slot Cover
150-F361FBD-BP SMC-FLEX, 361 A, 150...30
1492-SP3C020 SUPP. PROTECTOR MINI CIRCUIT BREAKER
Allen Bradley 17560W16I A Relay Isolated Output Module Ships Free Today
1492-M5X8V1-END Wiring System 5mm x 8mm 144 Mkrs/Crd
9301-2SE2400ITU2 RSVIEW32 WORKS 300-32K UPGRADE IN-SUPT (IT)
190E-DND1-CC16X 10 - 16 A 190E Eco Starter with CB
150-B54JBDB 150 Motor Controller
ALLEN BRADLEY COMMUNICATION ADAPTER MODULE 1785-KA3
1492-M5X10V21-40 Wiring System 5mm x 10mm 144 Mkrs/Crd
2711E-K10C15 PANELVIEW 1000E KEYPAD TERMINAL, 10.4" FLAT PANEL W/ VGA PIXEL GRAPHICS, CNET 1.5, DH+ & RI/O, NEMA 12, 13, 4X (INDOOR)
100-K05WJ01M IEC 5 A Contactor
194R-NJ400P34ER5 IEC Disconnect 400A Encl. N
2090-DAPC-D0901 CABLE, NON-FLEX, CN3 SERIAL COMMUNICATIONS, 01M
AllenBradley2711P-RP2A/F2711PRP2F
20BD014A0AYYAND1 PowerFlex 700 14 A 10 Hp AC Drive
Allen Bradley 1770-QT QC IT Keyboard Firmware A Ser A
Allen Bradley 1771-KA2 Communication Module
1756-PB72 ControlLogix DC Power Supply
191E-BND3-CB25X 191E Reversing EcoStarter w/CB
1109-DOB-EEM VAC STARTER 600A W/E10LR
20BD730A0ANNNND0 PowerFlex 700 730 A 600 Hp AC Drive
1233-BNBD-A2E-3-4LR-35 NEMA Size 1 Pump Panel,Slim line,CB Type
20DC037A0EYNACGNE PowerFlex 700S 37 A 18.5 kW AC Drive
2711-K10G1L1 PV1000 GRAYSCALE KEY, RIO & RS232 PRINT WITH RI/O COMMUNICATIONS & RS-232 PRINTER PORT
20BD8P0A0AYYANC0 PowerFlex 700 8 A 5 Hp AC Drive
1000K-34487003 KONE Starter Panel
112-C60FBE1G-6P-7 Fusible Disconnect Combination Starter
100S-C16DJ431C 16 A MCS Safety Contactor
103S-DTDJ2-CB10B 0.63 - 1 A MCS Starter & Circuit Breaker
ALLEN-BRADLEY 1203-GD1 SER B COMMUNICATIONS MODULE REMOTE I/O
190S-CNEJ2-DC10C 190S compact combination start
107S-ATEJ3-CB16B-TE 1 - 1.6 A Reversing Starter & Breaker
0041-5071 N-5600 SHAFT SEAL KIT
1238-102 PROBE BODY CLR ANDZD/DCA PRESS
Allen Bradley 8500-ANIO I/O Analog Module
Allen-Bradley 1336 Plus II Control Panel1336PLUS​II
112-3FBDE1F-DNF-7 Combination Starter
1395-117444 POLE PARTS,BUL-1370AR,600HP
100-K05ZA01M IEC 5 A Contactor
1734-ADNX 24V DC DEVICENET ADAPTER WITH SUBNET EXPANSION
1485A-C3 DeviceNet Accessory
152H-F251FBD-54-1F Controller w/Fusible Disconn
20F11GC030JA0NNNNN PowerFlex 753 AC Drive
20AD011A0AYNAEC0 PowerFlex 70 11 A 7.5 Hp AC Drive
112-C09ABE1C-1 Fusible Disonnect Combination Starter
1336-BDB-SP73D PCB GATE DRV 1336STEF 480V 300HP F FRAME
103T-AWD2-RB25B-C2A-KY Combination Starter
14185 Omron C200H-ID212 Input Module
1585-M8TBBM-12 Male Ethernet Media
9358-EP10ENE RSBIZWARE EPROCEDURE 10 UNITS
20BE041A3AYNADC0 PowerFlex 700 41 A 40 Hp AC Drive
20BD180A3ANNADA0 PowerFlex 700 180 A 150 Hp AC Drive
ALLEN BRADLEY FLEX I/O OUTPUT MODULE 1794-OB16P SER A HEY STICKER RESIDUE
2711-T6C3L1 ALLEN BRADLEY OPERATOR INTERFACE
1492-CAB015D69 Digital Cable Wiring System
Allen Bradley Operator Interface Monitor Screen Panel 6157-AABAAZAAZ​Z E20DPA
1492-M6X12V1-10 Wiring System 6mm x 12mm 120 Mkrs/Crd
1326AB-B420E-M2L MOTOR,SERVO,460V,5.0NM,3000RPM,MULTI,IP67
9399-INTDOSUG INTERCHANGE FOR DOS USERS GUIDE
Allen Heath GL2400-16 gl240016 PROAUDIOSTAR
191S-AND3-CB16S 1 - 1.6 A 191S Rev. Compact Starter w/CB
9399-RSBACLRG RSBATCH ACTIVE X CONTROLS LIBRARY REF. GUIDE
21T-179910-903-60C Trane LiquiFlo 2.0 AC Drive
20AC011A3AYNADC0 PowerFlex 70 11.5 A 5.5 kW AC Drive
Allen Bradley 1771-OBD 1771OBD Output Module 960207 Rev E3
109-C23ADE1E-4G Non-Reversing Starter
140M-C2E-C20-CX-KN-MT 140M Circuit Breaker
190S-DNZJ2-DB40C 2.5 - 4 A 190S Compact Comb Starter w/CB
1762-L40AWA MICROLOGIX 1200, 40 PT. (24) 120V AC IN, (16) RELAY OUT, AC POWER
Allen Bradley 1791-8BC SER B Module Block I/O P/N 96327672
20DD077A3EYNAEHNE PowerFlex 700S 77 A 60 Hp AC Drive
103S-AWD2-CB63C 4 - 6.3 A MCS Starter & Circuit Breaker
100-K05D200M IEC 5 A Contactor
Allen Bradley 2711P-T7D2 /A PanelView Plus 700 Color/Touch/Et​hernet/RS-232/​USB
1336-QOUT-SP15A TSTR,ASSY,OUTPUT,1336STG,575V,75HP
MPL-A430H-HJ24AA MOTOR,SERVO,6.55NM,3500RPM,ENCR,230V,BRK,8.2KG
190S-AND2-JB63C 4 - 6.3 A 190S Compact Comb Starter w/CB
20BC125A3ANNACC0 PowerFlex 700 125 A 55 kW AC Drive
1760-PICOPROPC02 PICOSOFTPRO W/PROG CABLE
20P21AF904RA0NNN PowerFlex 904 A DC Drive
AEG Schneider TSX SCG 116 1 TSXSCG1161 Communication Module
1233X-CNB-A2J-4LRG-42-900 NEMA Pump Panel,Extra space,Cype
20BD077A0ANNAND1 PowerFlex 700 77 A 60 Hp AC Drive
112-C12AHD1D-6P Fusible Disconnect Combination Starter
1492-FB2J60-L 2 POLE FUSE J60 ILLUM
150-C37FBD-900 NEMA 37A 150 Motor Controller
9701-VWMR075AS SUPT RENEWAL CONTRACT FOR 9701VWMR075AENE RSVIEW ME STATION RUNTIME (WINDOWS 2000) SOFTWARE
20DD065A0EYNANACE PowerFlex 700S 65 A 50 Hp AC Drive
ALLEN BRADLEY 1771KA2 COMMUNICATION ADAPTER MODULE DAT
1494G-CF3N-98-412 NEMA 60A Enclosed Disconnect
190E-AND2-CB10C-KN-TE 0.63 - 1 A 190E Eco Starter with CB
103S-DWD3-DB25CC-KN-R-SP-TE MCS Starter & Circuit Breaker
ALLEN BRADLEY 1771-IDC INSOLATED AC/DC INPUT MODULE
20C60M0ANNBNA0 PowerFlex 700H 460 A 250 kW AC Drive
1734-IJ 5 VDC INCREMENTAL ENCODER MODULE
100-C12ZS10 12 A 100-C contactor
190S-AND2-CB10C-R 190S Compact Comb Starter w/CB
029057 PepperlFuchs Proximity Switch IRH-30GM-V1
20AE017A3AYNNEC0 PowerFlex 70 17 A 15 Hp AC Drive
2090-SCEP10-0 SERCOS FBR CABL,CONN,ENCLOSURE ONLY PLASTIC,10.0M
190S-DND2-DC20C-KY-R 190S Compact Comb Starter w/CB
140M-F8N-C25-BX MOTOR CIRCUIT PROTECTOR
140M-F-W633 Compact Busbar
Allen-Bradley 1794-IB16
20BD4A0AYYACC1 PowerFlex 700 3.4 A 2 Hp AC Drive
20DE650N0NNNBNCEL 650 A 700 Hp AC Drive
100-C16N400 16 A 100-C contactor
194C-C10-3503 IEC CONTROL SW CHANGEOVER 1-0-2 60 10A
9301-2SE2300PTU2 RSVIEW32 WORKS 150-1500 UPGRADE IN-SUPT (PT)
20AD011A3AYNADG0 PowerFlex 70 11 A 7.5 Hp AC Drive
103T-CWD3-RC16A-E1E-KN IEC Combination Starter
9324-RLD250FRE RSLOGIX 5000 LITE EDITION FRENCH
100S-C09UDJ404BC 9A MCS Safety Contactor
1492-CM800-LA001 Conversion Module
103T-DWD2-RB40R-E1C-KN-V Combination Starter
190E-KMND2-CB25A-KY 1.6 - 2.5 A 190E Eco Starter with CB
152H-F25FCDB-42-3-4G-6P Controller w/Fusible Disconn
20BC072A0AYNADB0 PowerFlex 700 72 A 37 kW AC Drive
1492-M5X5VU151-200 1492-M5X5 marker card Wiring System
20BC037A0NYNANC1 PowerFlex 700 37 A 18.5 kW AC Drive
104-C85F22 85 A Reversing Contactor
1760-USB-PICO Pico USB Programmer Cable
1493-N3 KIT,OVERLOAD RELAY RESET FOR STARTER
1485G-P6N5-M5 DeviceNet Physical Media
152H-F43FBD-44-1F-4R-6P-8L-HC3 Controller w/Fusible Disconn
12000-SIP-501 FREE 1 YR CISCO SIP501 PROCESSOR
1492-F1GY TERMINAL BLOCK,GRAY 300V MAX
194E-A-PL11 AUXILIARY CONTACT BLOCK 25 - 100A
1492-H2GL TERMINAL BLOCK 600V MAX
20DD011A3EYNANCNL PowerFlex 700S 11 A 7.5 Hp AC Drive