1755-N2

1755-N2
1755-N2
1755-N2


宝钢二期烧结工程主排风机设备1991年投入运行。主排风系统由2台21000m3 /min风量，1 7 . 6 4 k Pa (1800mmWG)静压差的双入离心式风机机组组成，主拖动电机为 2×7800kW，10kV无刷励磁同步电动机，2台电机共用一套3.4MVA变频软起动装置起动。该装置1991年投产以来，故障较多，启动成功率低。其主要原因是装置设计容量偏小，系统老化，参数漂移。随着宝钢生产节奏的进一步加快，对烧结矿生产的要求越来越高，为确保烧结生产的稳定运行，基于2DL主排风机起动装置及励磁装置的实际现状，对其进行整体改造的确势在必行。
　　二、改造范围简述
　　本改造项目不涉及主排风机本体及油泵、风门等辅机设备。对目前使用状况尚好的为辅机及辅助设备供电、控制服务的MCC柜以及关联二烧结主控制系统的远程I/O柜予以保留利用。
　　对于10kV的高压开关，保留，能源部设置的辅助继电器、原有中继端子柜也予以保留。
　　高压变频装置、励磁柜、操作控柜拟引进设备，对其进行整体更换。与变频装置配套的输入、输出变压器则由外商提供详细技术参数及制造要求，由宝钢方面择优从内制造厂订货，变压器采用油浸式变压器。
　　考虑到本改造项目新上一套主排风机起动装置及励磁系统，而且在新系统安装调试好以前，老系统还要能运行使用，要求新系统电机空载或带风机负荷调试只能利用2DL年修的七天左右时间完成。当新系统调试过程中出现问题，不能如期接班时，还需老系统作为后备，维持2DL的正常生产。
　　新起动系统10kV运行总线的两路旁路开关到二台同步电动机的馈电，接至老系统运行总线下的两路旁路开关，主排风机室电动机那段电缆仍用旧有电缆。新老系统试车或运行需重接高压柜的高压电缆进行相互切换。
　　原有老系统的励磁柜、操作控盘拆除后，不再恢复。而新装的本次引进系统之励磁柜及操作、控制、视盘将要兼顾新老系统，这部分设备做成与新老系统兼容且具双向切换功能。
装置特点
　　本高压变频器作为软起动器可以连续起动，起动时间小于200秒，起动电流不超过电机的额定电流。该产品特点为：
　　可靠性高。该产品采用6500V,1500A 的高压SGCT器件，器件数量少，耐压及电流裕量大，变频电流小，器件开关损耗少，设备可靠。
　　输入波形好。变频整流器采用多脉冲形式(18脉冲)，总体谐波畸变THD小于 5%，直接满足IEEE519-1992及标的谐波标准。
　　输出波形好。无需增加任何选项， PWM电流型变频器直接输出完正弦波形，不存在转矩脉动，无潜在共振问题。逆变时无dv/dt及di/dt的产生，谐波畸变THD小于5%，连接变频器及电机之间的距离可长达15km。
　　起动性能好。PowerFlex7000采用直接矢量控制技术，本方案选用无编码器的矢量控制，转子的位置可直接检测，起动力矩为95%额定起动转矩。
　　使用简单。人机接口为大屏幕液晶显示操作员终端。变频器的状态，输入输出变量，自诊断结果，故障报等信息均可显示在屏幕上。
　　维护方便。高集成度的SGCT器件及 PowerCage机架的使用提高了系统模块化程度，从而保证了功率模块的更换时间小于5分钟。


191S-AND3-CB40C-R 191S REV. COMPACT COMB.STARTER,2.5 - 4 A
190E-DND2-CC25S-R 18 - 25 A 190E Eco Starter with CB
1494H-EF3H6 Hey Duty Fusible Safety Switch
1769-CRL1 CompactLogix Bus Expansion Cable
1492-25T PNL MNT BLOCK,HIGH TEMP,1-POLE
1788-EN2DN ETHERNET/IP TO DEVICENET LINKING DEVICE
20DE017A0EYNANANE PowerFlex 700S 17 A 15 Hp AC Drive
20BD180A3ANNADC0 PowerFlex 700 180 A 150 Hp AC Drive
190S-DNDJ2-CC20C-KY 190S Compact Comb Starter w/CB
140U-M5D3-D80 M frame molded case circuit-breaker
ALLEN BRADLEY 1492-AIFM4-3 INTERFACE MODULE SER A
103S-DWD6-DC16A-KN 10 - 16 A MCS Starter & Circuit Breaker
ALLEN BRADLEY 700-HN128 NSPP 700HN128
109-C30FDE1T-3-4G-7 Non-Reversing Starter
141A-VS510136F Supply Terminal Module
ALLEN BRADLEY 2711-K5A5L11
ALLEN-BRADLEY PANELVIEW 2711-T51A2L1 Touchscreen Glass
103S-ATD8-CA16D-KN-R-TE MCS Starter & Circuit Breaker
140M-K8P-D12 MOTOR CIRCUIT PROTECTOR
20BJ156A0AYNANA0 PowerFlex 700 156 A 125 Hp. AC Drive
20BR156A0QYNAND0 PowerFlex 700 156 A 125 Hp.. AC Drive
103T-ASD2-RB63CL-C2B-KN-TE IEC Combination Starter
Allen Bradley 1771-0A AC Output Module Series B
20BD125A0NNNANB0 PowerFlex 700 125 A 100 Hp AC Drive
AB Flex I/O 1794 -IA8 120 VAC Input Module
20BD052A3AYNANC0NNAD PowerFlex 700 52 A 40 Hp AC Drive
100S-C09K32BC 9 A MCS Safety Contactor
20BD011A3AYYANC1NNAE PowerFlex 700 11 A 7.5 Hp AC Drive
109-C72AAE1G Non-Reversing Starter
103S-GWP3-F5C-KN 32 - 45 A MCS Starter & Circuit Breaker
1492-MS8X12V1-END Wiring System 8mm x 12mm 56 Mkrs/Crd
190S-FNDJ4-FC20D-A20 190S Compact Comb Starter w/CB
21WD125A3AYNAHANBN 21W AC DRV,480 VAC,3 PH125 A,IP20/TYPE 1
1492-M5X12HGND Wiring System 5mm x 12mm 144 Mkrs/Crd
140M-D8N-C10-AD MOTOR CIRCUIT PROTECTOR
109-C12ADE1S-3 Non-Reversing Starter
Allen Bradley 1771 OA AC Output Module Ser B 120V
1494V-DJ633-F 30A Variable-Depth Disconnect Kit
6401-DDMCR 6401-DDMC SOFTWARE SUPPORT REINSTATEMENT
190S-BND2-CC10C-KN-S11 190S Compact Comb Starter w/CB
2094-PRS1 POWER RAIL, SLIM, 230V OR 460V, 1 AXIS
Alcatel SNC9AAAAAB HIF103 ICS01 OC-3 interface module
1585J-M4TB-2 RJ45 Ethernet Media
Allen Bradley 2711-K6C15 2711K6C15 /C Panelview 600 REM FACTORY SEALED
20BC875A0ANNNNC1 PowerFlex 700 875 A 500 kW AC Drive
194E-Y25M-1753-6G IP65 (Thermoplastic) Load Switch
20BB4P2A3NYYBDC0 PowerFlex 700 4.2 A 1 Hp AC Drive
1797-ACNR15 REDUNDANT MEDIA CONTROLNET EX ADAPTER
100-K05B10M IEC 5 A Contactor
1494C-DR611-A3-B-D-E 100A Cable Operated Disconnect Kit
1494V-DH622-A-E-F 200A Variable-Depth Disconnect Kit
100-C16N10 16 A 100-C contactor
194L-A16-3252 Control and Load Switch
100-KFA31ZM AUXILIARY CONTACT-BLOCK
MPL-B330P-RJ22AA MOTOR,SERVO,4.18 NM,5000RPM,RSLVR,460V,5.9KG
1489-D200 UL489 40 A DC Miniature Circuit-Breaker
1585J-M8PBJM-20X DNET RJ45 CROSSOVER CABLE
ALLEN BRADLEY OPERATOR INTERFACE 2711-K9C1 SER. C REV. L FRN 4.20 PARTS/REPAIR
20P-S520L 115VAC TO 24VDC 8 CH I/O CONVERTER BOARD
1585J-L8HBJM-8 Ethernet Media RJ45, Patchcord, 8m L
Allen Bradley KADZ PCP Circuit Board 8000-KAD 900034
55 X 23 X 4.5 Steel Cast Iron T-Slotted Table Layout Welding
1785-L40B PLC-5 Processor
20AD022A3AYYACG1 PowerFlex 70 22 A 15 Hp AC Drive
152H-F361FBD-57-6P-HC3 Controller w/Fusible Disconn
ALLEN BRADLEY 2711-T6C9L1/A PANELVIEW REMANUFACTURE​D
100-K09ZA10 IEC 9 A Contactor
190E-ANEJ2-CA63X-R00 0.4 - 0.63 A 190E Eco Starter with CB
100-0L400 40 A 100-C contactor
ALLEN BRADLEY SLC 500 1746-BAS BASIC MODULE SER C FRN 5 PLC COMMUNICATION CARD
103S-AWDJ3-CB16B 1 - 1.6 A MCS Starter & Circuit Breaker
20BD027A3AYNACC1 PowerFlex 700 27 A 20 Hp AC Drive
194E-FA16 Load Switch
Adaptec Inc. Circuit Board 400106-00 Rev D 4OO1O6-OO
140U-M5D3-D30 M frame molded case circuit-breaker
100-C16D01 IEC 16 A 100-C contactor
Analog Devices 3B41-02 ISO WB V Input Module Warranty
1585J-M4UBJM-25 RJ45 Ethernet Media
21T-180180-A07-6BC LiquiFlo 2.0 Trane Corp 900 A AC Drive
20DM1K520NNNECANE PowerFlex 700S 1500 A 1500 kW AC Drive
Bogen TNG1S Tone Generator Input Module
191E-AND3-CB63S-KN 4 - 6.3 A 191E Reversing EcoStarter w/CB
1492-81506-5 POLE CENTER JUMPER
190E-ANB1-CB16B 1 - 1.6 A 190E Eco Starter with CB
Automation Direct D3-16ND2F Input Module 24VDC H13 728
ALLEN BRADLEY PANELVIEW 550 2711 B5A15 SERIES H 2005 DATE FRN 4.41 TOUCH/BUTTONS
20DD011A0NYYACHNE PowerFlex 700S 11 A 7.5 Hp AC Drive
193-T1AB40 2.9-4.0 A Bimetallic Overload Relay
20BD040A0AYNANB0 PowerFlex 700 40 A 30 Hp AC Drive
2090-XXNFN-S25 TERM-198749Q25
141A-B3010C 1200 mm Length 30X10 mm Copper Busbar
1411-2SHT-500 MODEL 2SHT, 50:5 RATIO
20AD011A0AYNACG0 PowerFlex 70 11 A 7.5 Hp AC Drive
105-C23FDD1E-7 Reversing Starter
190S-AND2-CB16C-R-S10 1 - 1.6 A 190S Compact Comb Starter w/CB
Allen-Bradley 800T-H17
103S-DTZJ3-CC20C-SP MCS Starter & Circuit Breaker
ALLEN BRADLEY 1746-NIO4V 1746NIO4V
21T-351893-A02 Kit LiquiFlo Inverter Power Board
20G1AGD186AA0NNNNN PowerFlex 755 AC Drive
194E-CA63E-P11 Load Switch
Murr Elektronik 24V AC/DC DIN-Rail Mounting Relay Interface Module 51620
ALLEN BRADLEY 2711E-T10C6 SERIES D 10.4" TOUCH SCREEN OPERATOR INTERFACE
Allen-Bradley Open Type Switch 1494V-DS30 Ser. B1494VDS3014​94V-DS3O1494V​DS3O
1794-IR8 Flex 8 Point Distributed I/O Comb Module
194R-J30-1753-PBR1 Fused Disconnect Switch
Allen Bradley 2711-K6C15 2711K6C15 /C Panelview 600 REM FACTORY SEALED
100S-D420EP22C 420 A MCS Safety Contactor
20CE416ACANNBNB0 PowerFlex 700H 416 A 450 Hp AC Drive
Allen-Bradley 1771-HS3CR
20BD022A3AYYANB0 PowerFlex 700 22 A 15 Hp AC Drive
Allen Bradley 1785-KA Communication Adapter Module
1492-ACABLE090Y Analog Cable Wiring System
20BD077A3NYNACB0 PowerFlex 700 77 A 60 Hp AC Drive
1485G-F5R5-F5 DeviceNet Physical Media
103S-ETL3-DC16C-KN-SP-TE 10 - 16 A MCS Starter & Circuit Breaker
20BD034M0AYNANC0 PowerFlex 700 34 A 25 Hp AC Drive
MPL-A320H-MJ22AA MOTOR,SERVO,2.26 NM,3500RPM,MULTI,230V,4.0KG
1771-WF FIELD WIRING ARM 18 TERMINALS
1494C-DJX633-A3-B-F 30A Cable Operated Disconnect Kit
21A271 COIL,550V 60HZ FOR CONTACTOR OR STARTER
20DD027A3EYYANGNL PowerFlex 700S 27 A 20 Hp AC Drive
ALLEN BRADLEY 1771-ALX USPP 1771ALX
21VD4A3AYNANC0BN 21V Fan & Pump Packaged Drive
191E-ANEJ3-CB63C 4 - 6.3 A 191E Reversing EcoStarter w/CB
103S-CWD3-CB63C-KY-V 4 - 6.3 A MCS Starter & Circuit Breaker
20DD022A3EYNACAAE PowerFlex 700S 22 A 15 Hp AC Drive
191E-BND3-CC16C-KN-S11 10 - 16 A 191E Reversing EcoStarter w/CB
194R-LN Disconnect Terminal Shield
ALLEN BRADLEY 1746-IB32 DC INPUT MODULE
20BC325A0NNNNNC0 PowerFlex 700 325 A 180 kW AC Drive
1297-801 Pressure Gauge
194E-A16-NP LOAD SW
194L-G3667E ADD. LEGEND PLATE FOR SIZE 4 OR 6 BEZELS
ALLEN BRADLEY OUTPUT MODULE 1771-0D16 A 96098674 B01
455880-B21 HP Virtual Connect Flex-10 Switch C-Class BladeSystem HP RESeald
1794-TBNFQ28 FLEX TERM BASE, NEMA, FUSED (QTY 28)
1746-OA16 SLC 16 Point Digital Output Module
194R-NN100P31R3 KIT,DISCONNECT SW 600V AC MAX
Allen-Bradley 42SRU-6005
AMD Phenom X6 1055T 8GB 1TB Bly-Ray Radeon HD6870 Gamer
23B-D010DF0CNN-P3T 23B AC Packaged Drive
107S-ATZJ3-CB10C 0.63 - 1 A Reversing Starter & Breaker
103T-ATD3-QB25C-D1C Combination Starter
ALLENBRADLEY1771-OW16OUTPUTMODULE1771OW16
Allen Bradley PanelView 600 Plus 2711P-T6C5AX
1494V-DH622-A-B 200A Variable-Depth Disconnect Kit
1492-M6X12VR11-20 Wiring System 6mm x 12mm 120 Mkrs/Crd
Allen-Bradley 1336-MODKB010
103H-AFBD2-DB63X IEC Enclosed Combination Motor Controlle
20BD365A3ANNNNC1 PowerFlex 700 365 A 300 Hp AC Drive
1494V-DR644-D 400A Variable-Depth Disconnect Kit
20BD325N0QNNNND0 PowerFlex 700 325 A 250 Hp AC Drive
1492-CAB004J69 Digital Cable Wiring System
20BD4A3NYNACC0 PowerFlex 700 3.4 A 2 Hp AC Drive
112-3FBDE1F-1 Fusible Disconnect Combination Starter
20F14ND361AN0NNNNN PowerFlex 753 AC Drive
9324-RL0300DER SUPT REINSTATEMENT CONTRACT FOR 9324RL0300DE RSLOGIX 500 OFFLINE/ONLINE PROGRAMMING SOFTWARE (GERMAN)
140U-L6D3-D30-B L frame molded case circuit-breaker
140U-H3C3-C70-JB H frame molded case circuit-breaker
20BP170A0ANNANC0 PowerFlex 700 170 A 90 kW.. AC Drive
Beckhoff KL1702 Input Module
20BC125A0ANNANB0 PowerFlex 700 125 A 55 kW AC Drive
20BD180A3NYNANA0 PowerFlex 700 180 A 150 Hp AC Drive
1497B-A6-M13-3-N CONTROL POWER TRANSFORMER
Allen Bradley SLC 500 System – Input Module 1746-IV16
Allen Bradley 1746-1A16 Input Module
1494V-DR611 100 A Disconnect Switch
Allen-Bradley SLC500 Input Module 1746-IA16. Series C.
1494V-DH633-A-C-E-F 30A Variable-Depth Disconnect Kit
1497B-A14-M15-3-N CONTROL POWER TRANSFORMER
Acme TA-2-81220 CNC Control TRANSFORMER 3000 VA
1492-J70-B IEC 1-Ckt Feed-Through Blk 70mm
2090-UXNFBMP-S25 MP-Series 25 m Length Feedback Cable
1803-EEM02E12 EEM,16 ANALOG, 4 TO 20 MA, NEMA 12 ENCLOSURE
1492-SP3D630 IEC 63 A Miniature Circuit-Breaker
100-C30UH00 IEC 30 A 100-C contactor
Allen-Bradley 1771-ASB/E
1411-180RL-201 MODEL 180RL, 200:5 RATIO
1492-ACAB050BA69 Analog Cable Wiring System
1440-VDRS06-00RH XM 160 Overall Measurement Module
1494G-BF3N-98-203W NEMA 30A Enclosed Disconnect
190S-AND2-CA40C-KY-R 190S Compact Comb Starter w/CB
ALLEN BRADLEY 1783-MS10T
20DD460N3ENNBCANE PowerFlex 700S 460 A, 350 Hp AC Drive
20DC500ACENNBNANE 500 A 250 kW AC Drive
20DD8P0A3EYNANCNK PowerFlex 700S 8 A 5 Hp AC Drive
20DD034A3EYNANCSL PowerFlex 700S 34 A 25 Hp AC Drive
190E-CND2-DC16S-KY-R 10 - 16 A 190E Eco Starter with CB
20AD034C3AYYADC0 PowerFlex 70 34 A 25 Hp AC Drive
1492-SM6X35 TERMINAL BLOCK MARKER
1395-317027-A01 PCB FEEDBACK,575/600V,BUL 1395
112-C09AADE1C Fusible Disconnect Combination Starter
Allen Bradley 1771-IFE/C Analog Input Module 12 bit
113-C60FBDE1G-46-901 Circuit Breaker Combination Starter
20CE460A0ANNBNA0 PowerFlex 700H 460 A 500 Hp AC Drive
1233X-BNB-3-6P-35-901 NEMA Pump Panel,Extra space,Cype
103S-ATD3-DC10C-KN 6.3 - 10 A MCS Starter & Circuit Breaker