1606-XLPRED

1606-XLPRED
1606-XLPRED
1606-XLPRED


宝钢二期烧结工程主排风机设备1991年投入运行。主排风系统由2台21000m3 /min风量，1 7 . 6 4 k Pa (1800mmWG)静压差的双入离心式风机机组组成，主拖动电机为 2×7800kW，10kV无刷励磁同步电动机，2台电机共用一套3.4MVA变频软起动装置起动。该装置1991年投产以来，故障较多，启动成功率低。其主要原因是装置设计容量偏小，系统老化，参数漂移。随着宝钢生产节奏的进一步加快，对烧结矿生产的要求越来越高，为确保烧结生产的稳定运行，基于2DL主排风机起动装置及励磁装置的实际现状，对其进行整体改造的确势在必行。
　　二、改造范围简述
　　本改造项目不涉及主排风机本体及油泵、风门等辅机设备。对目前使用状况尚好的为辅机及辅助设备供电、控制服务的MCC柜以及关联二烧结主控制系统的远程I/O柜予以保留利用。
　　对于10kV的高压开关，保留，能源部设置的辅助继电器、原有中继端子柜也予以保留。
　　高压变频装置、励磁柜、操作控柜拟引进设备，对其进行整体更换。与变频装置配套的输入、输出变压器则由外商提供详细技术参数及制造要求，由宝钢方面择优从内制造厂订货，变压器采用油浸式变压器。
　　考虑到本改造项目新上一套主排风机起动装置及励磁系统，而且在新系统安装调试好以前，老系统还要能运行使用，要求新系统电机空载或带风机负荷调试只能利用2DL年修的七天左右时间完成。当新系统调试过程中出现问题，不能如期接班时，还需老系统作为后备，维持2DL的正常生产。
　　新起动系统10kV运行总线的两路旁路开关到二台同步电动机的馈电，接至老系统运行总线下的两路旁路开关，主排风机室电动机那段电缆仍用旧有电缆。新老系统试车或运行需重接高压柜的高压电缆进行相互切换。
　　原有老系统的励磁柜、操作控盘拆除后，不再恢复。而新装的本次引进系统之励磁柜及操作、控制、视盘将要兼顾新老系统，这部分设备做成与新老系统兼容且具双向切换功能。
装置特点
　　本高压变频器作为软起动器可以连续起动，起动时间小于200秒，起动电流不超过电机的额定电流。该产品特点为：
　　可靠性高。该产品采用6500V,1500A 的高压SGCT器件，器件数量少，耐压及电流裕量大，变频电流小，器件开关损耗少，设备可靠。
　　输入波形好。变频整流器采用多脉冲形式(18脉冲)，总体谐波畸变THD小于 5%，直接满足IEEE519-1992及标的谐波标准。
　　输出波形好。无需增加任何选项， PWM电流型变频器直接输出完正弦波形，不存在转矩脉动，无潜在共振问题。逆变时无dv/dt及di/dt的产生，谐波畸变THD小于5%，连接变频器及电机之间的距离可长达15km。
　　起动性能好。PowerFlex7000采用直接矢量控制技术，本方案选用无编码器的矢量控制，转子的位置可直接检测，起动力矩为95%额定起动转矩。
　　使用简单。人机接口为大屏幕液晶显示操作员终端。变频器的状态，输入输出变量，自诊断结果，故障报等信息均可显示在屏幕上。
　　维护方便。高集成度的SGCT器件及 PowerCage机架的使用提高了系统模块化程度，从而保证了功率模块的更换时间小于5分钟。


21T-180700-A05-9LC Carrier LiquiFlo 2.0 AC Drive
140U-J2D3-D20-VJ J frame molded case circuit-breaker
140M-H8P-D10-XF MOTOR CIRCUIT PROTECTOR
20BD065A3NYNACC1 PowerFlex 700 65 A 50 Hp AC Drive
190E-ANEJ2-CC10C-KN 6.3 - 10 A 190E Eco Starter with CB
Allen Bradley 1771-1A AC Input Module
F1771-DMCU FIRMWARE UPGRADE FOR 1771-DMC CONTROL COPROCESSOR
106-C09ABDD1C Reversing Combo Starter
2Watlow Firerod Cartridge Heater J3A89-L12
ALLEN-BRADLEY 1771-IA 120V AC INPUT MODULE
190E-BNKL2-CC16X 10 - 16 A 190E Eco Starter with CB
Allen-Bradley 1771-CP2
140U-J6S3-D25-TD J frame molded case circuit-breaker
152H-F480FBDB-58-4G-4R-8L Controller w/Fusible Disconn
ALLEN-BRADLEY 20-COMM-R SER.A POWERFLEX ARCHITECTURE CLASS REMOTE I/O COMM.
194E-FA00-PE Load Switch
194E-CA16EX-PD10-PE-6 Load Switch
9304-WRM300D WINTELLIGENT RECIPE
1485G-P5N5-M5 DeviceNet Physical Media
1232X-FNAD-28 NEMA Pump Panel,Extra space,DS Type
112-C23FBE1E-6P Fusible Disconnect Combination Starter
Amphenol/Madis​on Electronics Connector 2 Piece Hood D-Sub 17-1724-11717​241
Allen-Bradley 8000 MBA Module 905981-05 Rev A
194E-Y16-1753-4N IP65 Thermoplastic Load Switch
9301-2SE2303JPE RSVIEW32 WORKS 1500 WITH RSLINX (JAPANESE)
ALLEN BRADLEY ANALOG INPUT MODULE 1734-IE2C SER. A F/W REV. 1.003
9399-RSBARG RSBATCH ARCHIVER REFERENCE GUIDE
20AD014A3AYNAEG0 PowerFlex 70 14 A 10 Hp AC Drive
1492-HWACAB050M Honeywell Analog Cable Wiring System
20DD096A0NYNANANE 96 A 75 Hp AC Drive
100S-3K14C 43 A MCS Safety Contactor
9399-2SE32UG RSVIEW32 USER GUIDE
1492-M6X12V151-200 Wiring System 6mm x 12mm 120 Mkrs/Crd
1492-SP1D060-N SUPP. PROTECTOR MINI CIRCUIT BREAKER
Allen Bradley 1794-IE8 Ser.B Rev.P10 NIB
1757-UPGSIFO UPGRADE MOORE APACS QUICKBUILDER INTERFACE
20AD2P1F0AYNNDC0 PowerFlex 70 2.1 A 1 Hp AC Drive
1492-H2RA432 TERMINAL BLOCK 600V MAX
Allen Bradley Panelview 2711-KC1 Ser B Rev C FRN 2.00.00 Nice Unit Barely
140U-J6D3-D25-A J frame molded case circuit-breaker
1494V-DJ606-A-D-E-FF 600 A Variable-Depth Disconnect Kit DS
ALLEN BRADLEY 1746-IV16 SER. C INPUT MODULE 24VDC DC 16 POINT for SLC 500 SLC
20BC022A0AYNANC1 PowerFlex 700 22 A 11 kW AC Drive
109-CDED0-E1E-2 IEC Enclosed Non-Reversing Starter
20AD034M3AYYANC0 PowerFlex 70 34 A at 25 Hp AC Drive
100-C37X10 37 A 100-C contactor
190E-BND1-KC16C 10 - 16 A 190E Eco Starter with CB
103T-CSD2-RC16D-C2C Combination Starter
Allen-Bradley 1771-RTP3
ALLEN BRADLEY PANELVIEW DISPLAY INTERFACE 2711P-RDB10C 2711P-B10B1 2711P-RP1
2090-DANFCT-S12 CABLE, NF, MTR FBACK FOR CABLE-MTD CONN, T, 12M
1492-MS6X12V151-200S Wiring System 6mm x 12mm 80 Mkrs/Crd
152H-F85FBD-48-3-4G-4R-6P-8B Controller w/Fusible Disconn
190E-ANA2-CC10X 6.3 - 10 A 190E Eco Starter with CB
9356-PRO2300 RSSQL PROFESSIONAL VERSION WITH 1500 TAG LIMIT
1492-M5X5VR51-100 1492-M5X5 marker card Wiring System
1769-IQ16 16 POINT 24 VDC SINKING/SOURCING INPUT MODULE
Acer TrelMate TM6595T-52544G​50Mtkk 15.6" LED Notebook Intel Core i5 i5-2540M
1494V-DNX60-A-D-E-F 60A Variable-Depth Disconnect Kit
1414-ITS02GBRAA SPACE TEMPERATURE TRANSMI
140UE-LTI4-D63 IEC 630 A Trip Unit
MPL-A4530F-HJ22AA MOTOR,SERVO,8.36NM,2800RPM,ENCDR,230V,8.2KG
140U-H2C3-5-PJ H frame molded case circuit-breaker
103T-ATD2-QB25C-E1C-TE Combination Starter
20BD077A3AYNANC0 PowerFlex 700 77 A 60 Hp AC Drive
Allen-Bradley 6171-MX8
20CE208M0ANNBNA0 PowerFlex 700H 208 A 200 Hp AC Drive
1494C-DN200-A4-D1-H 200A Cable Operated Disconnect Kit
190S-FND3-F5C-KY 32 - 45 A 190S Compact Comb Starter w/CB
103S-AWD2-CC10C-KN 6.3 - 10 A MCS Starter & Circuit Breaker
Allen Bradley 1771-ODZ Isolated AC Output Module
1492-ACABLE095WB Analog Cable Wiring System
103T-AWKD2-QB10C-E1B Combination Starter
193-EF2CZJ Solid State 160-630 A Overload Relay
AB PLC AC Output Module 1794-OB16 1794OB16 NIB
21VD027A3AYNANC0BN 21V Fan & Pump Packaged Drive
190E-DNKP2-DC20C-F11 14.5 - 20 A 190E Eco Starter with CB
140M-J2E-D16-MU MOTOR PROTECTION CIRCUIT BREAKER
140U-H2C2-D12 125 A Molded Case Circuit-Breaker
190E-AND2-CC10C-R 6.3 - 10 A 190E Eco Starter with CB
103S-AWD2-CA25C-KN-V MCS Starter & Circuit Breaker
13.2" Window XP OS Intel Dual-core Laptop Notebook w/ WiFi Camera CPU Intel Ato
1321-3TW027-BB-JXCY71-004 CUSTOM ISOLATION TRANSFORMER
20BC043A3AYNANB0 PowerFlex 700 43 A 22 kW AC Drive
20BD8P0A0AYYAND0 PowerFlex 700 8 A 5 Hp AC Drive
20-750-EMC2-F2 PowerFlex 750 Size 2 Frame EMC Core Kit
9361-CHARTS SUPT RENEWAL CONTRACT FOR 9361CHART RSCHART ACTIVEX CONTROL SOFTWARE
194L-HE4A-528 ACTUATOR
1411-AL-600 MODEL AL, 60:5 RATIO
1492-CAB005F64 Digital Cable Wiring System
20AE9A3AYYNNC0 PowerFlex 70 3.9 A 3 Hp AC Drive
190S-BND2-CA16C 190S Compact Comb Starter w/CB
1790D-T8A0 DNET LDX , 120V AC, 8 INPUT BASE, TERMINAL BLOCK
112-C09FBE1E-6P Fusible Disconnect Combination Starter
9323-MX300ENR SUPT REINSTATEMENT CONTRACT FOR 9323MX300EN A.I. SERIES MICROLOGIX 1000 OFFLINE/ONLINE PROGRAMMING SOFTWARE
9380-RSBAR1000S SUPT RENEWAL CONTRACT FOR 9380RSBAR1000 RSBATCH RELATIONAL DATABASE ARCHIVER OPTION 1000
1397-419035-400JSA INVERT.FLT BKR,100HP,230V/200HP,460V
194L-E12-8761 Control and Load Switch
9301-2SE2503KOE RSVIEW32 WORKS 100K WITH RSLINX (KOREAN)
1485C-P1Z5-C DeviceNet Physical Media
ALLEN BRADLEY 836-N1 NSFP 836N1
194L-A12-4271 Control and Load Switch
140UE-H2E4-C63 IEC 63 A Molded Case Circuit-Breaker
1789-SL52 SoftLogix 5 Medium Software
107S-AWDJ3-CB63CK 4 - 6.3 A Reversing Starter & Breaker
1321-3R1-A 1321 Power Component 1 A Line Reactor
1492-JD3RB513 terminal block, resistor, 51.1K Ohms
153H-C108XBD-49 SMC-3 ENCLOSED COMBINATION 108A
20BC125A3ANNACC0 PowerFlex 700 125 A 55 kW AC Drive
140U-J3D3-D15-QJ J frame molded case circuit-breaker
1492-RCD4B40D RES CURRENT DEVICE
Allen Bradley 1771-OZL 1771OZL Contact Output NIB
1769-L30ER CompactLogix 1 MB Memory Controller
6186-M17ALTR VERSIEW 17 INCH MONITOR, RESISTIVE TOUCH SCREEN ALUMINUM BEZEL
100S-3DJ22C 43 A MCS Safety Contactor
1494C-DJ666-A4-B1-F 60A Cable Operated Disconnect Kit
105-PW43 Reversing Wiring Kit
109-C12ADE1R-3-7 Non-Reversing Starter
103S-GSKP2-F5C 32 - 45 A MCS Starter & Circuit Breaker
1232X-ENB-A2M-27R NEMA Pump Panel,Extra space,DS Type
1492-M5X8V141-150 Wiring System 5mm x 8mm 144 Mkrs/Crd
1494C-DN100-A3-D 100A Cable Operated Disconnect Kit
152H-C108FAD-46-3-6P-901 Controller w/Fusible Disconn Enclosed Mo
1232X-BNCD-3-4LG-24R NEMA Pump Panel,Extra space,DS Type
1202-RRC1 CABLE,REMOTE RESET FOR OVERLOAD RELAY
20DD1K0H0ENNBNANL PowerFlex 700S 1030 A 900 Hp AC Drive
1485RS-P3M5-C DeviceNet Physical Media
20AB4P2C3AYNAEC0 PowerFlex 70 4.2 A 1 Hp AC Drive
1492-GS3G025 3 POLE HIGH DEN. SLIM MINI.CB 2.5 A
153H-C60FBD-46-3-6P Controller w/Circuit Breaker Enclosed Mo
140U-H2C2-C80 80 A Molded Case Circuit-Breaker
20AE022F0AYNNNC0 PowerFlex 70 22 A 20 Hp AC Drive
2090-CDNPBMP-8S15 CABLE,460V,NON-FLEX,MOTOR POWER,MP,8 GAUGE,15M
1771-IJC SER A FIRMWARE REV G 1 YEAR GUARANTEE
100S-C09KJ422C 9A MCS Safety Contactor
103H-CFBDJ2-DC16X IEC Enclosed Combination Motor Controlle
20AB2P2A0AYNANC0 PowerFlex 70 2.2 A 0.5 Hp AC Drive
1497D-A17-M24-0-N GEN PURPOSE TRANSFORMER
20BR156A3ANNACC1 PowerFlex 700 156 A 125 Hp.. AC Drive
2090-XXNPMP-8S05 MP-Series 5 m Length Power Cable
152H-F108FBD-49-4G-6P-8L-HC3 Controller w/Fusible Disconn
GML-DSR SUPT REINSTATEMENT CONTRACT FOR GMLDS GRAPHICAL MOTION CONTROL LANGUAGE (GML) SOFTWARE FOR IMC S CLASS
Allen Bradley Input Module 1756-IF16
1756-M02AS 1756 2 AXIS ANALOG/SSI SERVO MODULE
2090-CPBM6DF-16AA09 TL-Series 9 m Length Pwr and Brake Cable
20DR156A0ENNANANE PowerFlex 700S 156 A 125 Hp AC Drive
1492-MR6X8H51-100 1492-MR6X8 marker card Wiring System
20G11GD4AA0NNNNN PowerFlex 755 AC Drive
1492-M5X12VR51-100 1492-M5x12 marker card Wiring System
103S-ATDJ2-CA40C-TE MCS Starter & Circuit Breaker
Allen Bradley 1771-IAD Input Module
191E-ANKD3-CB25C 191E Reversing EcoStarter w/CB
104-C09KN22 9A Reversing Contactor
1585D-E4TBDE-3 Micro D-Code, QD Style Ethernet Media
112-C09ABE1C-DNF-6P-7 IEC Enclosed Combination Starter
1494C-DN30-A3-B1-E-F 30A Cable Operated Disconnect Kit
AB Allen Bradley 1771-IBD Series B 10 to 30 VDC Input Module PLC 1771IBD
Allen Bradley 1771 IAD input module
103S-AWKF2-CB16C 1 - 1.6 A MCS Starter & Circuit Breaker
194E-G3688 Load Switch Operating Shaft
1771-NT1 HIGH RESOLUTION ISOLATED ANALOG MODULE (8) TC/MV IN, RECOMMEND 1771-RTP1 & (2) 1771-NC6 OR NC15
194R-FJ200P3 Fused Disconnect Switch
15 HP GE Direct Current Spindle Shunt Motor CD259AT
1585D-F4UB-2 Ethernet Media M12, Cordset
100-CTL23 Load Side Terminal
112-C12FBJE1C-3-4R-6P Fusible Disconnect Combination Starter
2100PE-WLGJT40/2 LVMCC
140U-H-XFC01 Circuit-Breaker Accessory
ALLEN BRADLEY 1794-IV16 INPUT MODULE 1794IV16 FACTORY SEALED
ADAPTEC 2244300-R 5805 8-channel pci express lp w/cable
104-3T22 43 A Reversing Contactor
153H-DF251FHD-51-6PK SOLID-STATE CONTROLLER WI
9392-CDRSITE DATADISC ENGLISH/ITALIAN BUNDLE
2711P-RGT6 PROTECTIVE ANTIGLARE OVERLAY,QTY 3,PVP 600 TOUCH FOR PV PLUS 600 TOUCH
22D-B2P3N104 PowerFlex 40P 0.4 kW (0.5 Hp) AC Drive
107S-DTD3-CC25X 18 - 25 A Reversing Starter & Breaker
109-C12ADXXX-T Non-Reversing Starter
20BB015A0NYNBNC0 PowerFlex 700 15.3 A 7.5 Hp AC Drive
Allen-Bradley 2711-TC1-B PanelView Touch Screen
1492-HWACAB090UB Honeywell Analog Cable Wiring System
1492-HWACAB250UB Honeywell Analog Cable Wiring System
ALLEN BRADLEY 2711-TC1 SERIES E PANELVIEW 1200 TERMINAL
9392-CDRSPTU UPGRADE TO ENGLISH/PORTUGUESE BUNDLE
2090-XXNFY-S09 Y-Series 9 m Length Feedback Cable
20BB104A3AYNACD0 PowerFlex 700 104 A 40 Hp AC Drive
20AB9P6A3AYYNNC0 PowerFlex 70 9.6 A 3 Hp AC Drive
2092-DA4 DRIVE, 10.7A/24.8A, ULTRA1500 DIGITAL SERVO DRIVE
1490-N3 CONDUIT CONN, 1 in.
20BE6P1A3AYNANA0 PowerFlex 700 6.1 A 5 Hp AC Drive
1489-A3D250R UL489 MINI CIRCUIT BIEC60947-2 MINI CIRC
Allen Bradley SLC 500 Output Module 1746-OA16 Ser B
190E-AND2-DB25R-V 1.6 - 2.5 A 190E Eco Starter with CB
9301-2SE3350R SUPT REINSTATEMENT CONTRACT FOR 93012SE3350 RSVIEW32 RUNTIME 5000 SOFTWARE
1411-8SHT-122 MODEL 8SHT, 1200:5 RATIO
103S-DTDJ2-CB10B 0.63 - 1 A MCS Starter & Circuit Breaker
140-KRY Lockable Twist Knob
190E-BND2-DB40B 2.5 - 4 A 190E Eco Starter with CB
1492-ACS025B LA Water Analog Cable Wiring System