1771-WHF

1771-WHF
1771-WHF
1771-WHF


宝钢二期烧结工程主排风机设备1991年投入运行。主排风系统由2台21000m3 /min风量，1 7 . 6 4 k Pa (1800mmWG)静压差的双入离心式风机机组组成，主拖动电机为 2×7800kW，10kV无刷励磁同步电动机，2台电机共用一套3.4MVA变频软起动装置起动。该装置1991年投产以来，故障较多，启动成功率低。其主要原因是装置设计容量偏小，系统老化，参数漂移。随着宝钢生产节奏的进一步加快，对烧结矿生产的要求越来越高，为确保烧结生产的稳定运行，基于2DL主排风机起动装置及励磁装置的实际现状，对其进行整体改造的确势在必行。
　　二、改造范围简述
　　本改造项目不涉及主排风机本体及油泵、风门等辅机设备。对目前使用状况尚好的为辅机及辅助设备供电、控制服务的MCC柜以及关联二烧结主控制系统的远程I/O柜予以保留利用。
　　对于10kV的高压开关，保留，能源部设置的辅助继电器、原有中继端子柜也予以保留。
　　高压变频装置、励磁柜、操作控柜拟引进设备，对其进行整体更换。与变频装置配套的输入、输出变压器则由外商提供详细技术参数及制造要求，由宝钢方面择优从内制造厂订货，变压器采用油浸式变压器。
　　考虑到本改造项目新上一套主排风机起动装置及励磁系统，而且在新系统安装调试好以前，老系统还要能运行使用，要求新系统电机空载或带风机负荷调试只能利用2DL年修的七天左右时间完成。当新系统调试过程中出现问题，不能如期接班时，还需老系统作为后备，维持2DL的正常生产。
　　新起动系统10kV运行总线的两路旁路开关到二台同步电动机的馈电，接至老系统运行总线下的两路旁路开关，主排风机室电动机那段电缆仍用旧有电缆。新老系统试车或运行需重接高压柜的高压电缆进行相互切换。
　　原有老系统的励磁柜、操作控盘拆除后，不再恢复。而新装的本次引进系统之励磁柜及操作、控制、视盘将要兼顾新老系统，这部分设备做成与新老系统兼容且具双向切换功能。
装置特点
　　本高压变频器作为软起动器可以连续起动，起动时间小于200秒，起动电流不超过电机的额定电流。该产品特点为：
　　可靠性高。该产品采用6500V,1500A 的高压SGCT器件，器件数量少，耐压及电流裕量大，变频电流小，器件开关损耗少，设备可靠。
　　输入波形好。变频整流器采用多脉冲形式(18脉冲)，总体谐波畸变THD小于 5%，直接满足IEEE519-1992及标的谐波标准。
　　输出波形好。无需增加任何选项， PWM电流型变频器直接输出完正弦波形，不存在转矩脉动，无潜在共振问题。逆变时无dv/dt及di/dt的产生，谐波畸变THD小于5%，连接变频器及电机之间的距离可长达15km。
　　起动性能好。PowerFlex7000采用直接矢量控制技术，本方案选用无编码器的矢量控制，转子的位置可直接检测，起动力矩为95%额定起动转矩。
　　使用简单。人机接口为大屏幕液晶显示操作员终端。变频器的状态，输入输出变量，自诊断结果，故障报等信息均可显示在屏幕上。
　　维护方便。高集成度的SGCT器件及 PowerCage机架的使用提高了系统模块化程度，从而保证了功率模块的更换时间小于5分钟。


20DD385A3ENNBDANE 385 A 300 Hp AC Drive
152H-F60FBD-46-3-6P-20E Controller w/Fusible Disconn
ALLEN BRADLEY SLC 500 OUTPUT MODULE 1746-OB8 SER A
20BD065A0AYNAEC1 PowerFlex 700 65 A 50 Hp AC Drive
9324-RLD300NXITE RSLOGIX 5000 STD., RSNETWORX BUNDLE, ITA
Allen Bradley 2705-P31J1 Operator Interface 7207
140UE-H7E4-C25 IEC 25 A Molded Case Circuit-Breaker
190S-ANDJ2-CB10C-S10 190S Compact Comb Starter w/CB
100-C30A00 30 A 100-C contactor
140M-C2E-C16-CX-KN MOTOR PROTECTION CIRCUIT BREAKER
9358-HSTCLTENE RSBIZWARE HISTORIAN SINGLE USER RUN TIME CLIENT
2090-UXNPBMP-10S03 CABLE,460V,NON-FLEX,MOTOR POWER,MP,10 GAUGE,3M
20DD077A3EYNADACE PowerFlex 700S 77 A 60 Hp AC Drive
1756-DMF30K 1-AX DRVCTRLSF3000 CONFOR
190E-AND2-CB40S-R 2.5 - 4 A 190E Eco Starter with CB
1492-MR8X12H31-40 Wiring System 8mm x12mm 84 Mkrs/Crd
20DC5P0A0EYNANCNK PowerFlex 700S 5 A 2.2 kW AC Drive
Acer TrelMate TM6595T-6427 NX.V4BAA.001 15.6" i5-2540M 2.60GHz 4GB 500GB Win7
20BC043A0AYNADD1 PowerFlex 700 43 A 22 kW AC Drive
20AB054A0NYNANC0 PowerFlex 70 54 A 20 Hp AC Drive
1796-PM30007 PM3000 DEMO, DENMARK 220V
191E-AND3-CA40C-F22-R 191E Reversing EcoStarter w/CB
D1761-6.3 MICROLOGIX 1000 PROGRAMMABLE CONTROL.USER MANUAL
1414-CTQ0BDAA DUCT TEMPERATURE TRANSMIT
20DF052A0EYNANANE PowerFlex 700S 52 A 45 kW AC Drive
AB Output Module 1746-IV16 1746IV16 NIB
107S-ATDJ3-CB10C 0.63 - 1 A Reversing Starter & Breaker
1492-H4 4 square mm Fuse Terminal Block
9323-PA1FR SUPT REINSTATEMENT CONTRACT FOR 932A1F 6200 SERIES MICROLOGIX 1000 PROGRAMMING - FRENCH SOFTWARE
1489-A3C070R UL489 MINI CIRCUIT BIEC60947-2 MINI CIRC
9399-WSPUG WINTELLIGENT QUALITY USE GUIDE
20AD065C3AYNAEC0 PowerFlex 70 65 A 50 Hp AC Drive
194E-AA16E-P11 NEMA Type 1 - IP54 Load Switch
150-B180NCDA-8B 150 Motor Controller
100-C16UH10 16 A 100-C contactor
103S-BWD3-CC10C-KY 6.3 - 10 A MCS Starter & Circuit Breaker
9301-2SE240PTU3R RSVIEW32 WORKS 150-32K UPGRADE OUT-SUPT (PT)
1494C-DN400-A5-F 400A Cable Operated Disconnect Kit
20AD014A3AYYAEC0 PowerFlex 70 14 A 10 Hp AC Drive
140-CMN-4000-CN-KN MOTOR PROTECTION CIRCUIT BREAKER
107S-AWD3-CB25C 1.6 - 2.5 A Reversing Starter & Breaker
107S-AWZJ3-CC10C 6.3 - 10 A Reversing Starter & Breaker
20BR248A0NNNANC0 PowerFlex 700 248 A 200 Hp.. AC Drive
1769-L35CR CompactLogix 1.5MB ControlNet Controller
1485F-P2N5-A DeviceNet Physical Media
150-B500NBRA 150 Motor Controller
103T-F3-RC10C-E1D-KN-R-SP IEC Combination Starter
20BD125F0AYNAEC0 PowerFlex 700 125 A 100 Hp AC Drive
57C380 Reliance Electric Communication Module DCS Pass
21AD052E3AYNAND0NNNN-ND-B0-C1-J2-J4-J8-N2-P6-S1-S9-S10-S13 PowerFlex 70 Packaged Drive
9301-2SE2300FRS SUPT RENEWAL CONTRACT FOR 93012SE2300F RSVIEW32 WORKS 1500 SOFTWARE (FRENCH)
1336-MOD-RP1 REMOTE PROGRAMMING PANEL
2090-XXNPMF-14S04 MP-Series 4 m Length Pwr and Brake Cable
103S-JTD3-GC90C 63 - 90 A MCS Starter & Circuit Breaker
20BB022A0AYNBNC0 PowerFlex 700 22 A 7.5 Hp AC Drive
2711-B6C16 ALLEN BRADLEY OPERATOR INTERFACE 1YR WARRA
Allen Bradley 1769-IQ16 | DC Input Module
10V2160 GV3000 V Per Freq - Vector AC Drive
20DD022A0EYNACASE PowerFlex 700S 22 A 15 Hp AC Drive
140U-N0H3-E12 N frame molded case circuit-breaker
20BB022A3AYNBED0 PowerFlex 700 22 A 7.5 Hp AC Drive
Allen Bradley Servo Drive CSDJ-10BX2 1kW
Allen Bradley 1746-OV16 SLC 500 OUTPUT Module Ser C
ALLEN BRADLEY PANELVIEW 900 OPERATOR KEYPAD MONITOR 2711-K9A5 2711K9A5 SER F
9352-WAB300D WINTELLIGENT LINX FOR ALLEN-BRADLEY PROGRAMMABLE CONTROLLERS
100-C16KG10 16 A 100-C contactor
1746-RT30 SLC Terminal Block
140M-RC2N-B25 MAG ONLY TRIP,2.5A
20DD2P1A3EYNA1CBK PowerFlex 700S 2.1 A 1 Hp AC Drive
20DH590H0ENNBNABE PowerFlex 700S 590 A 315 kW AC Drive
2098-DSD-HV100-SE Ultra 3000 Servo Drive
112-3FCDXXX-7 Fusible Disconnect Combination Starter
9358-HSTS2500U3R UPGRADE: OUT-SUPT: HISTORIAN 1500 TO 70K TAG
103T-FTDJ3-T5D-C2D-F11-KN Combination Starter
1585-M8UBBM-12 Ethernet Media Variant 1, Patchcord
20CJ730N3ANNNNB0 PowerFlex 700H 730 A 600Hp AC Drive
Allen Bradley Input Module 1771-IA2 29000
20DD014A3EYNAEAEL PowerFlex 700S 14 A 10 Hp AC Drive
2711P-T6C8A PV PLUS 600 COLOR, TOUCH, DH+, AC PS INCL RS232, ETHERNET & USB, 32MB FLASH/64MB RAM
1492-CAB050A7S Digital Cable Wiring System
20DD014A3EYNAEHNE PowerFlex 700S 14 A 10 Hp AC Drive
9324-RLD300ENS SUPT RENEWAL CONTRACT FOR 9324RLD300EN CONTROLLOGIX AND RSLOGIX 5000 OFFLINE/ONLINE PROGRAMMING SOFTWARE
190E-CND2-CC10R-KY 6.3 - 10 A 190E Eco Starter with CB
20F11NC022JA0NNNNN PowerFlex 753 AC Drive
1606-XLSBAT1 UPS Battery - 7AH Power Supply
190E-DNH2-DC20X 14.5 - 20 A 190E Eco Starter with CB
Channel Plus 5525 Two Input Modulator
194R-NH100P31R4 KIT,DISCONNECT SW 600V AC MAX
Allen Bradley 2706-NG1 Message Display Accessory ++
100-C09UEJ01 9 A 100-C contactor
23B-D024D104NN-P3T 23B AC Packaged Drive
100-CR16D200 16 A 100-C contactor
2100PE-WLHQB41/1 LVMCC
2090-UXNPAMP-8S01 CABLE,230V,NON-FLEX,MOTOR POWER,MP,8 GAUGE,1M
20BD022A0AYNANA0 PowerFlex 700 22 A 15 Hp AC Drive
1321-3RA45-C 1321 Power Component 45 A Line Reactor
150-B180NCDA-8B 150 Motor Controller
2008 OKUMA Servo Motor BL-80E-20T NO ENCODER BL80E20T NO ENCODER
9399-RSBARG RSBATCH ARCHIVER REFERENCE GUIDE
1492-M6X5V31-40 Wiring System 6mm x 5mm 200 Mkrs/Crd
2711P-K7C6D2 PV PLUS 700, KEYPAD, RIO/DH, DC PS, EXT MEM INCL RIO, DH+, DH-485, RS232, ETHERNET, USB
105-C09FDD1A Reversing Starter
Allen Badley 1734-IB8 Input Module
1585D-M4TBDM-70 Micro D-Code, QD Style Ethernet Media
140U-L3D3-D50-GJ L frame molded case circuit-breaker
190E-KMNDJ2-CB63A-KY 4 - 6.3 A 190E Eco Starter with CB
1497-L-ABDX-0-N Control Circuit Transformer
107S-ATDJ3-CB63C-TE 4 - 6.3 A Reversing Starter & Breaker
20MD500NNNNNNNN0 20MD500NNNNNNNN0
152H-F201FBD-52-6P-8B Controller w/Fusible Disconn
20DC030A0EYNANABL PowerFlex 700S 30 A 15 kW AC Drive
190S-ANDJ1-CB40C-S10 2.5 - 4 A 190S Compact Comb Starter w/CB
150-F251NCDB CONTROLLER MOTOR 480V MAX
1797-TB3S 3-WIRE EX TERMINAL BASE - SPRING CLAMP
190S-BND2-CC16C-TE 10 - 16 A 190S Compact Comb Starter w/CB
112-3FBE1F-1-4G-6P-8 Fusible Disconnect Combination Starter
112-C09ABD1D-6P Fusible Disconnect Combination Starter
194R-HAIRPIN Disconnect Cotter Pin
104-C97D22 97 A Reversing Contactor
103S-AWD2-DB63R 4 - 6.3 A MCS Starter & Circuit Breaker
20DE1K1A0ENNBNANE PowerFlex 700S 1180 A 1300 Hp AC Drive
1000F-1791ES-IB8X0BV4 1791 Ford Safety Module
1492-CABLE050RTBB Digital Cable Wiring System
20CD1K1A0ANNBNN0 PowerFlex 700H 1150 A 1000 Hp AC Drive
103S-AWKG3-CB63C 4 - 6.3 A MCS Starter & Circuit Breaker
9399-WINIGIT INSTAL'ION GUIDE FOR WINDOWS-BASED PROD.(ITALIAN)
ALLEN BRADLEY 1771-IVN 1771IVN 10-30VDC LOW TRUE INPUT MODULEw/WARRANTY
21CD385BPANNBNB0NNNN-ND-B0-C1-P6-S51-S59-S60-S63 21C AC Configured Drive
20AD4A3AYYAEC1 PowerFlex 70 3.4 A 2 Hp AC Drive
20CC500A0ANNBNN0 PowerFlex 700H 500 A 250 kW AC Drive
199-LG1 Disconnect Terminal Lugs
1757-UPGSIFH UPGRADE HW MICROMAX LPU QUICKBUILDER I/F ONE MAJOR RELEASE LEVEL
0041-5061 F-Series Shaft Seal Kit
20DD077A0EYNACASE PowerFlex 700S 77 A 60 Hp AC Drive
194R-CC30-1753S-PY Fused Disconnect Switch
1497B-A3-M16-3-N CONTROL POWER TRANSFORMER
20AC2P1A0AYNACC0 PowerFlex 70 2.1 A at 0.75 kW AC Drive
9301-2SE3400ITU3 RSVIEW32 RUNTIME 150-32K UPGRADE IN-SUPT (IT)
100-C37YJ-E10 IEC 37 A Contactor
1785-ACC5LA ACCESSORY KIT FOR PLC-5/11,5/20
150-B54NCDA-8M 150 Motor Controller
Allen Bradley Panelview 2711-KC1 Ser B Rev C FRN 2.00.00 Nice Unit Barely
194R-KJ100P3E IEC DISCONNECT, 100A, ENCL. K
1771-N2 EMPTY SLOT FILLER CARD
194R-60-C1 Term Cover 1 Pole 60A Rotary Disconnect
103S-GTDJ3-F5C-KY-TE 32-45 A MCS Starter & Circuit Breaker
1497B-A3-M16-1-N CONTROL POWER TRANSFORMER
103S-ATDJ2-CB16C-SP-TE 1 - 1.6 A MCS Starter & Circuit Breaker
191S-AND3-CB10C-KN 191S Rev. Compact Starter w/CB
20CD261A3ANNNNB0 PowerFlex 700H 261 A 200 Hp AC Drive
153H-F108FBDB-49-HC3 Controller w/Circuit Breaker
Allen-Bradley DC Input Module 1756IB16
190S-DNF2-CC20C 190S Compact Comb Starter w/CB
2090-CPWM7DF-10AA09 9 m Length SpeedTec Standard Power Cable
20DH1K3ACENNBNANE 1300 A 710 kW AC Drive
100S-C16EJ404C 16 A MCS Safety Contactor
20DD011A3EYNAEAEE PowerFlex 700S 11 A 7.5 Hp AC Drive
190E-ANEJ2-CA40C 0.25 - 0.4 A 190E Eco Starter with CB
Allen Bradley 2711E-K10C15 /D 2711EK10C15 Panelview 1000e
1336-BDB-SP9D PCB,GATE DRIVE,1336STG,575V,15HP
1497B-A6-M17-1-N CONTROL POWER TRANSFORMER
1232X-BNCD-A2J-24R NEMA Pump Panel,Extra space,DS Type
Allen Bradley Photoswitch Inductive Proximity Control 871T-G5A18 871TG5A18
20BD156A0NNNACD1 PowerFlex 700 156 A 125 Hp AC Drive
20AD8P0A3AYYACG0 PowerFlex 70 8 A 5 Hp AC Drive
1492-ACABLE016Y Analog Cable Wiring System
109-C23ABD1E-6P Non-Reversing Starter
103T-ETKP3-TC25C-E1E Combination Starter
1796-FLEXLOGIX2 FLEXLOGIX DEMO 220 EUROPE
103S-AWD3-CB25R MCS Starter & Circuit Breaker
20AD2P1A3AYNNDG0 PowerFlex 70 2.1 A 1 Hp AC Drive
20DD011A0EYNANBNE PowerFlex 700S 11 A 7.5 Hp AC Drive
2092-DA4 Ultra 1500 Servo Drive
1326AB-B730E-S2K7L MTR SRV 460V 39.0NM 3350RPM SNG BRK IP67
140M-C2T-C10-CC-KY MOTOR PROTECTION CIRCUIT BREAKER
1796-FLEXLGXLC2 IDP FLEXLOGIX LC DEMO 220 EUROPEAN STD.
1492-SP3C100 SUPP. PROTECTOR MINI CIRCUIT BREAKER
1494V-DN400-A-D-F 400A Variable-Depth Disconnect Kit
1786-FSB500 200 MICRON BULK CABLE 500 METERS (1640 FT)
2100-APP-P-3 LVMCC Documentation for 2100-APP-P-3
Automation Direct Input Module T1K-16ND3 Warranty
20DD300A0EYNNCANE 300 A 250 Hp AC Drive
Allen-Bradley 1318-BOA005
190E-AND2-CB63R-KN-S10 4 - 6.3 A 190E Eco Starter with CB
1492-LD4RB124 terminal block, resistor, 121K Ohms
20AB2P2A0AYNNNC0 PowerFlex 70 2.2 A 0.5 Hp AC Drive
ALLEN-BRADLEY MICROLOGIX 1200 1762-OF4 4 CH. ANALOG OUTPUT MODULE SER QUANTITY
20AB4P2C3AYNAEC0 PowerFlex 70 4.2 A 1 Hp AC Drive
1492-MC5X8V201-300S 1492-MC5x8 marker card Wiring System
20BD5P0A3NYNACD1 PowerFlex 700 5 A 3 Hp AC Drive
190E-AND2-CB63R-S10 4 - 6.3 A 190E Eco Starter with CB
21VD8P0A0AYNANC0BN 21V Fan & Pump Packaged Drive
21VE6P1A3AYNNEC0BN-LR 21V Fan & Pump Packaged Drive
103T-ATD3-RB63X-D1D-KN-TE IEC Combination Starter
1485R-P25M5-M5 DNET MALE TO MALE THIN
190E-AND2-CC10C-KN 6.3 - 10 A 190E Eco Starter with CB
ALLEN-BRADLEY 2711-B5A2 Panelview 550 Series F WOW
1489-A3D150 UL489 MINI CIRCUIT BIEC60947-2 MINI CIRC