1756-IV32

1756-IV32
1756-IV32
1756-IV32


　每家生产工厂都很关注电力管理。
　　自主提供部分电能的工厂尤其关注这一点，特别是在工厂需要依靠电力实现持续运行时。位于密歇根的一家造纸厂便是如此。
　　断电可能导致停机、生产损失以及设备损坏，代价高昂。为缓解此问题，电力质量的重要性日渐凸显;由于容差范围窄，设备和制造过程中很难利用质量差的供电。
　　造纸厂尤其受到此类问题的困扰。
　　在与罗克韦尔自动化电力及能源管理解决方案小组(PEMS) 合作之前，该造纸厂一直在承受每年四至七次断电带来的负面影响。
　　为帮助像们这样每天依靠电力实现赢利的工厂，PEMS专门设计了一套解决方案来连续测电力，并控制负载的自动切换，以维持工厂的正常生产。除此之外，整套解决方案还能提供分析和培训，帮助工厂员工更深入地了解电力管理挑战，以及如何应对这些挑战。
　　面临的挑战
　　面临的挑战是如何掌握电力使用情况，并在不中断造纸过程的前提下切换电源。
　　该厂有两台造纸机专门生产用作包装材料的瓦楞纸板。工厂总负载的60%由现场的15兆瓦涡轮发电机承担，其余部分则由当地公共电力提供。过去，在当地公共电力停止供电时，涡轮发电机就需要满足整个工厂的负载需求，进行导致其跳闸离线，断电屡有发生。
　　这些电力故障造成整个工厂长时间停机、设备受损、生产受阻。之后，还需要耗费大量精力使工厂恢复生产。
　　解决方案
　　在权衡PEMS解决方案的价值以及断电造成的收益损失之后，该公司认为这一投资物有所值，因此决定由PEMS开发一套紧急负载卸载系统解决方案。
　　PEMS为该厂提供了一套负载管理及控制系统(LMCS)，其中配备的自动切换系统可以快速从正常运转模式转换到应急模式，以满足工厂中关键的电力需求。PEMS解决方案基于成熟且极为可靠的Allen-Bradley可编程逻辑控制器和电力测器系列产品，可使涡轮发电机、锅炉及关键设备持续运转，保证工厂造纸过程不被中断。该系统能将非关键负载切换为离线状态，并能在不到266ms或12个周期的时间内将工厂从公共电网中隔离出来。
　　LMCS可对电压、电流及其它电力参数进行实时视。其中包含的紧急负载卸载算法可实现对非关键负载控制(卸载)的快速响应。切换过程只需几毫秒，因此，当主要的公共电力中断时，完全可以通过辅助电源维持关键负载的运转，从而维持生产。LMCS还会提示和记录异常事件(报)，连续视公共电网提供的电力，在遇到紧急情况时几乎可以瞬间自动将负载切换为离线状态，从而确保13.8kV线的稳定。
　　在构建系统之前，PEMS先进行了现场调查和需求分析。们制定了包含I/O及电力测器详细列表的功能规范，确定了将要采用的通信网络，并且明确了将所有功能整合在一起所需的硬件和软件。
　　此外，们还与工厂沟通确定了人机界面(HMI)站的配置，同时定义了将未来扩展考虑在内的自动化控制算法和要求规范。
　　PEMS提供的解决方案中还整合了其它一些服务，例如软件和硬件工程、设计和起草、面板装配以及PLC编程。工厂验收试验也顺利执行。整个解决方案安装到位后，工厂得到了一套终文档，从而完成了所有设计及操作知识的交接。


2711-K5A2 PV550 MONOCHROME KEY, DH485 WITH DH-485 COMMUNICATIONS
1000-5XX-SP-E NEMA SIZE 4 SPECIAL
140U-H3C3-5-MB H frame molded case circuit-breaker
1233V-ENB-50T NEMA Size 4 Pump Panel w/ Vacuum Cont,CB
ANALOG DEVICES 5V 5kHz EXCITATION LVDT INPUT MODULE 3B17-02
1494C-DR611-A3-E-F Cable Operated Disconnect Kit Cable Disc
1492-TPJ6 Test Adaptor
1799-DSSCON D-SUB(50) I/O MATING CONNECTOR (SOLDER)
190E-AND2-CB16C-F11 1 - 1.6 A 190E Eco Starter with CB
150-F201FBDB-6PX-8L-HC3 150 Motor Controller
Allen-Bradley 1774-SR
104-K12ZD02 IEC Reversing Contactor
2090-UXNFBY-S30 CABLE,ULGRF50ON-FLEX,MOTOR FEEDBACK,Y,30M
103S-DWZJ2-CC25C 18 - 25 A MCS Starter & Circuit Breaker
Mitel Interface Module 2 9132-250-101-N​A WARRANTY
ALLEN-BRADLEY 160-BA01NPS1P1 0.5HP 460VAC Control. in good condition
153H-F25FBDB-41-8L Controller w/Circuit Breaker
CRESTRON ST-IO ST-10 8 RELAY 4 DIGITAL/ANALOG INPUT MODULE low-voltage relays
ALLEN BRADLEY 1492-EA35 USPP 1492EA35
AGRAMKOW I/O MODULE 4 INPUT/4 OUTPUT
100-C23UDJ01 23 A 100-C contactor
Allen Bradley Redi-Panel 2705-K12C3 Series E
20-750-20COMM PowerFlex 750 20COMM Carrier Kit
20DC500A3ENNBCAEE PowerFlex 700S 500 A 250 kW AC Drive
194E-G3665M Metric ABS Enclosure
20DD052A3EYNAEGNE PowerFlex 700S 52 A 40 Hp AC Drive
Allen Bradley 1771-IXHR /B 1771IXHR B THERMOCOUPLE MILLIVOLT INPUT MODULE
1585BX-M8UBBM-7 Ethernet Media Variant 1, Patchcord
ALLEN-BRADLEY 1771- IA2 120V AC INPUT MODULE
103T-BWD2-RB63C-E1D-KN Combination Starter
2098-DSD-020-DN DRIVE, 10A/30A, ULTRA3000 W/DEVICENET
1492-HM3BL TERMINAL BLOCK 600V MAX
22F-D1P5N103 PowerFlex 4M 0.4 kW (0.5 Hp) AC Drive
1.25 x 1.25 x 5 Kennametal Tool Holder DDJNL-205C
20P41AD1K3RA0NNN PowerFlex 1328 A DC Drive
140M-C2E-B16-CC-KY MOTOR PROTECTION CIRCUIT BREAKER
1492-FB1M30-D1 1P FUSE MID IL 12-72V
100S-C12ZJ32C 12 A MCS Safety Contactor
152H-C201FBD-52 Controller w/Fusible Disconn
160-DN2 DeviceNet Series A-C Interface Module
150-F625JBE-20C 150 Motor Controller
9371-EPCO3R SUPT REINSTATEMENT CONTRACT FOR 9371EPCO3 RSWIRE EDS ISA PCS OPTION
103S-GSD2-F5C-KY-MS 32 - 45 A MCS Starter & Circuit Breaker
1585J-M8VBJM-15 RJ45 Ethernet Media
152H-80JBD-59-6P-8B Controller w/Fusible Disconn
100-C23G10 23 A 100-C contactor
20DF119A0ENNANANE PowerFlex 700S 119 A 110 kW AC Drive
ALLEN BRADLEY 1771-IBD INPUT MODULE 10-30VDC
190E-DND1-DB40C-TE 190E ECO STARTER, 2.5 - 4 AMP, W/ 100-C
1771-OFE2 ALLEN BRADLEY OUTPUT MODULE ANALOG 4POINT
152H-C201XBD-51 152H-C201XBD-51
6640-NAA0R 6640-NAA0 SOFTWARE SUPPORT REINSTATEMENT
112-C09FBE1B Fusible Disconnect Combination Starter
193-T1DC75 58-75 A Bimetallic Overload Relay
190E-AND2-CB10B 0.63 - 1 A 190E Eco Starter with CB
1794-TB3TSQ28 Flex Pack of 28 Terminal Base
1492-HC6-BP PANEL MOUNT BLOCK
Acer TrelMate TM8573T-9627 NX.V4EAA.002 15.6" i7-2640M 2.80GHz 8GB 500GB Win7
ALLENBRADLEY1746-NO8IANALOGOUTPUTMODULE1746NO8I1746-N08I
112-C23AHJD1D-DNF-3-7-901-901T Combination Starter
F1785-L60LSERD FIRMWARE UPGRADE FOR 1785-L60L PLC5 PROCESSOR MODU
103SS-ATDJ2-CB16C-KY-SP-TE IEC Safety Combination Starter
191E-AND3-CB10C-R 191E Reversing EcoStarter w/CB
1492-J120 TERMINAL BLK
Bernecker Rainer Input Module Analog ECPE82-1
11 PCS 10 Diamond Abrasives Cut Off Grinding Wheel
1492-M6X12VU31-40 Wiring System 6mm x 12mm 120 Mkrs/Crd
100-K09KJ300 IEC 9 A Contactor
1485K-P6D5-C DeviceNet Physical Media
1492-ACABLE150Y Analog Cable Wiring System
140U-H2C3-D10-PJ H frame molded case circuit-breaker
190S-ANEJ1-CB40C-TE 2.5 - 4 A 190S Compact Comb Starter w/CB
150-F780NCAB CONTROLLER,MOTOR 480V MAX
20BR125A0ANNACC1 PowerFlex 700 125 A 100 Hp.. AC Drive
20DC205A0NYNACANE PowerFlex 700S 205 A 110 kW AC Drive
20BC170A3ANNADC0 PowerFlex 700 170 A 90 kW AC Drive
SIEMENS 6ES7441-2AA03-​0AE0 COMMUNICATION MODULE CARD 62671
20CD300M3ANNBNB0 PowerFlex 700H 300 A 250 Hp AC Drive
140-LY120 Pilot Light
D6195-6.5.5 CONTROLVIEW BUILDER GETTING STARTED MANUAL
140M-F8E-C32-KN-MT-RX-TE 140M Circuit Breaker
140U-I6C3-C90-M 90 A Molded Case Circuit-Breaker
112-C60AHE1G-7-901 IEC Enclosed Combination Starter
1420-V1P PowerMonitor 500 Power Meter
AB PLC Output Module 1762-OB8 1762OB8 In Box
150-C108FHD NEMA 108A 150 Motor Controller
ADEPT TECH 30332-12350 INTERFACE MODULE SIO 3033212350
1494G-EF3R6-203W-414-421 NEMA 200A Enclosed Disconnect
20AC030M3AYNANC0 PowerFlex 70 30 A 15 kW AC Drive
103S-CWD3-DC16R-R 10 - 16 A MCS Starter & Circuit Breaker
20BD096A3QNNANC0 PowerFlex 700 96 A 75 Hp AC Drive
103T-ASD3-RB63D-C2A Combination Starter
AllenBradley2711-T10C20/D2711T10C20Panelview1000MfgRefurbished
194L-E16-3751 Control and Load Switch
1492-LD4SS 2-Ckt Feed-Through Blk, MOV, 4mm
103T-AWD3-RB63D-C2B-F11-KN-V IEC Combination Starter
3INA BEARING Bearings PN NK19/20
1734-OE2V 24V DC 2 CHANNEL ANALOG VOLTAGE OUTPUT MODULE
20P41AF1K2RA0NNN PowerFlex 1243 A DC Drive
190S-ANKD2-CB25C-TE 190S Compact Comb Starter w/CB
1492-CAB008A69 Digital Cable Wiring System
2090-XXTPMP-10S30 MP-Series 30 m Length Power Cable
20BD875A0ANNNND0 PowerFlex 700 875 A 700 Hp AC Drive
9399-RSVSPCGR RSVIEW32 SPC GETTING RESULTS GUIDE
153H-F135FBD-50-3-4R-8L-HC3 Controller w/Circuit Breaker
BRUEL KJAER INPUT MODULE 3015
Allen Bradley 1771-IBD B Rev E03 Input Module 10-30 VDC Series B PLC AB 1771IBD
Allen Bradley 1771-IAD/D Input Module
2006-2010 MERCEDES BENZ E350550 TELE AID COMMUNICATION MODULE 2118203826
152H-F625JBD-61-1F-6P Controller w/Fusible Disconn
20BD096A3QNNANC0NNAD PowerFlex 700 96 A 75 Hp AC Drive
103S-CTZJ2-CC16BC 10 - 16 A MCS Starter & Circuit Breaker
AllenBradley1756-OB16ISIsolatedOutputModuleControlLogix
150-B54NBD-8L 150 Motor Controller
190E-BND2-CB63R 4 - 6.3 A 190E Eco Starter with CB
ALLEN BRADLEY 1764 OX8 OUTPUT MODULE
100-C12ZA01 12 A 100-C contactor
20AD8P0A0AYNNCC1 PowerFlex 70 8 A 5 Hp AC Drive
1715-IF16 1715 16 Analog Input Module
20AD011A0AYNACC0 PowerFlex 70 11 A 7.5 Hp AC Drive
191S-ANB3-CB63C 4 - 6.3 A 191S Rev. Compact Starter w/CB
1494V-DN30-F 30A Variable-Depth Disconnect Kit
20DD022A3EYNANACE PowerFlex 700S 22 A 15 Hp AC Drive
20AD2P1C3AYNNDC1 PowerFlex 70 2.1 A 1 Hp AC Drive
153H-F480FBD-59-1F-6PX-HC3 Controller w/Circuit Breaker
20BE125A0ANNANC0 PowerFlex 700 125 A 125 Hp AC Drive
107S-ASJ3-CB40C-KY-V IEC Reversing Combination Starter
1585BX-M8TBBM-75 Male Ethernet Media
MPL-A4520K-HJ24AA MOTOR,SERVO,6.10NM,4000RPM,ENCR,230V,BRK,9.5KG
1786-BNC IMPROVED CONTROLNET RG6 COAXIAL CONNECTOR 75 OHM CRIMP TYPE (PRICED PER PIECE, SOLD IN LOTS OF 50)
103T-ATDJ2-RB63X-E1C Combination Starter
Siemens 6ES7 153-2BA02-0XB0 Simatic S7 Profibus Interface Module w/bad door
ALLEN BRADLEY 1771-IBD DC INPUT MODULE
194E-CA63E Load Switch
SuperMicro H8DCL-I
140U-K-FCS04 Circuit-Breaker Accessory
194L-HE4A-901 ACTUATOR
1232X-CNAD-26J NEMA Pump Panel,Extra space,DS Type
Allen Bradley 1785-BCM Series B Output Module
20DD040A3EYNARHNE 40 A 30 Hp AC Drive
190E-AND2-CB25X-R 1.6 - 2.5 A 190E Eco Starter with CB
190E-AND2-CB16X-KY-TE 1 - 1.6 A 190E Eco Starter with CB
MPL-A320H-MJ22AA MOTOR,SERVO,2.26 NM,3500RPM,MULTI,230V,4.0KG
1756-M23 LOGIX5555 1.5MBYTE NONVOLATILE MEMORY
190S-ANZJ2-DC10C-KY 190S Compact Comb Starter w/CB
103T-EWD2-RB63B-C1B-F20-KN-V Combination Starter
100S-3UA14C 43 A MCS Safety Contactor
Accesslan Communications 4-Port DS3 Broadband Trunk Module DS3-4 w/ UCS Card
140M-F8E-C25-CX-KN MOTOR PROTECTION CIRCUIT BREAKER
1757-DNBUPG03 DEVICENET LIC UPG 3 DNB ONE RELEASE LEVEL
1769-PB4 CompactLogix Power Supply
190E-BNKD2-CC10B 6.3 - 10 A 190E Eco Starter with CB
F1785-L20C15SERD FIRMWARE UPGRADE FOR 1785-L20C15 PLC5 PROCESSOR MO
AllenBradleyProgramingterminal
20DC2P1A3EYNANGNE PowerFlex 700S 2.1 A 0.75 kW AC Drive
140M-C2T-B40-TE MOTOR PROTECTION CIRCUIT
ALLEN BRADLEY DATALINER INTERFACE 2706-A41J SERIES D
20DD027A3EYYAEASE PowerFlex 700S 27 A 20 Hp AC Drive
140UE-L3F3-D32 IEC MoldedCase Circuit Breaker
20BD2P1A0NYNADD0 PowerFlex 700 2.1 A 1 Hp AC Drive
100-3F00 43 A 100-C contactor
191E-AND3-DC10C-F11-KY-S20 191E Reversing EcoStarter w/CB
20CD590N0ANNBNA0 PowerFlex 700H 590 A 500 Hp AC Drive
9351-OSFS SUPT RENEWAL CONTRACT FOR 9351OSF INTERCHANGE FOR OSF/1 SOFTWARE
20DD034A3EYNA5CBK PowerFlex 700S 34 A 25 Hp AC Drive
20DC170A3NNNACASE PowerFlex 700S 170 A 90 kW AC Drive
153H-B135HBD-50-NB Controller w/Circuit Breaker
100-NX227 IEC 30 A Contactor
Agilent / HP J2299B T1/ISDN Interface Module For J230
2711-T6C16L1 PV600 COLOR TOUCH, DF1 & RS232 PRINT WITH DF1 COMMUNICATION & RS-232 PRINTER PORT
156-B25CA3 25 A Contactor
1485G-P1W5-R5 DeviceNet Physical Media
100-3KD00 43 A 100-C contactor
1756-IT6I ControlLogix 6 Point Input Module
21BD027ACAYNANC0NNNN-ND-B0-C1-P6 PowerFlex 700 Packaged Drive Bulletin 21
1771-IVN LOW-TRUE INPUT MODULE, 10-30V DC, 32 INPUT
20F14NC085AA0NNNNN PowerFlex 753 AC Drive
160-RFB-14-A RFI FILTER 3 PHASE 200-460VAC 14.2A
20BD052A3NYNANN0 PowerFlex 700 52 A 40 Hp AC Drive
20BD156A0AYNADC0 PowerFlex 700 156 A 125 Hp AC Drive
191S-ANKP3-CB40C 2.5 - 4 A 191S Rev. Compact Starter w/CB
194E-AA80 Load Switch
ALLEN BRADLEY FLEX I/O 24VDC INPUT MODULE 1794-IB16 SER.A W/ BASE 1794-TB3
190S-DNDJ2-CC20D 190S Compact Comb Starter w/CB
ALLEN BRADLEY 1771-IGD TTL INPUT MODULE XLNT
9301-2SE3400FRU5 RSVIEW32 RUNTIME 5K-32K UPGRADE IN-SUPT (FR)
20DD4A0NYNANANE PowerFlex 700S 3.4 A 2 Hp AC Drive
AMD PHENOM X2 550 MSI MOTHERBOARD CPU DDR3 MEMORY COMBO
140M-I8E-D10E-GJ MOTOR PROTECTION CIRCUIT BREAKER
100S-C12KA23BC 12 A MCS Safety Contactor
1000GD-376EAH466 GDI , EAH Family, LS, 460V, w/ CM
22D-E0F104 PowerFlex 40P 1.5 kW (2 Hp) AC Drive
140U-Q6D3-D60-HJ Q frame molded case circuit-breaker
100-C23ZW10 23 A 100-C contactor
1494G-BF3N-412 NEMA 30A Enclosed Disconnect
103H-AFCD2-DB25X-KY IEC Enclosed Combination Motor Controlle
190E-ANEJ2-CB40R-F11-S10 2.5 - 4 A 190E Eco Starter with CB
100-FL11KJ Mechanical Latch